1993 JEEP GRAND WAGONEER Recalls (7)
- Campaign:
- 92V181000 on 12/29/1992
- Component:
- Service brakes, hydraulic:pedals and linkages
- Manufactured:
- 09/30/1992 - 09/30/1992
- Affected:
- 600
- Defect:
- The retainer clip which secures the master cylinder input rod to the brake pedal was not installed properly, and could work loose.
- Consequence:
- Disengagement of the retainer clip will allow free playin the attachment and can allow the input rod to separate from the brake pedalcausing complete loss of brake application which could result in an accident.
- Correction:
- Improperly installed retainer clips will be removed and new retainer clips will be properly installed.
- Notes:
- System: brakes.vehicle description: grand cherokee and grand wagoneer utility vehicles.
- Campaign:
- 93V051000 on 04/07/1993
- Component:
- Suspension:front
- Manufactured:
- 12/31/1992 - 02/28/1993
- Affected:
- 25,000
- Defect:
- The eccentric cam adjuster bolts in both front lower suspension arm-to-front axle bracket attachments may fail due to assembly misalignment.
- Consequence:
- Cam bolt failures cause the vehicle to pull to oneside when the brakes are applied, resulting in a possible loss of vehiclecontrol and an accident.
- Correction:
- Replace the front suspension cam bolts, cam washers, and nuts with components of a different design.
- Notes:
- System: front suspension.vehicle description: sport utility vehicles.
- Campaign:
- 93V055000 on 04/27/1993
- Component:
- Structure:body:hatchback/liftgate
- Manufactured:
- 12/31/1991 - 09/30/1992
- Affected:
- 80,000
- Defect:
- Grease applied to the liftgate latch rubber bumpers to ease component assembly caused the bumper to swell, interfering with the movement of the liftgate latch pawl. this prevents the liftgate latching when closed and difficult to open when latched.
- Consequence:
- An unlatched liftgate can open while the vehicle is inmotion, and could result in an occupant falling out.
- Correction:
- Replace the liftgate assembly on affected vehicles.
- Notes:
- System: structure; lift gate.vehicle description: utility vehicles; model grand cherokee and grand wagoneer.
- Campaign:
- 93V210000 on 12/29/1993
- Component:
- Steering:wheel and handle bar
- Affected:
- 115,000
- Defect:
- The molded plastic pin which connects the upper steering column shaft and the lower column shaft may have been sheared prior to installation of the steering column assembly into the vehicle. if this occurred, the upper steering shaft will separate from the lower steering shaft.
- Consequence:
- If the upper and lower steering shafts separate, completeloss of steering control will occur, which could result in an accident.
- Correction:
- A restraining sleeve will be added to the intermediate shaft to limit the amount of steering shaft movement available.
- Notes:
- System: steering; column shaft; upper.vehicle description: multipurpose passenger vehicles.note: if you have a problem obtaining the needed repair, please contact thechrysler zone office in your area. it is listed under "service assistance" inyour owner's manual. a zone representative will arrange for prompt attention toyour vehicle. also contact the national highway traffic safety administration'sauto safety hotline at 1-800-424-9393.
- Campaign:
- 96I004000 on 10/21/1996
- Component:
- Seat belts:rear
- Affected:
- 224,642
- Defect:
- This is not a safety recall in accordance with federal regulation 573. however, it is deemed a safety improvement campaign by the agency. the center rear seat belt buckle may not be accessible when the right (passenger) side of the rear seat back is folded down in the cargo stowage position.
- Consequence:
- In the event of a collision, the occupant of the center rear seat may not be properly restrained and personal injury could occur.
- Correction:
- Dealers will replace the seat belt buckle assembly.
- Notes:
- Note:chrysler has decided to conduct a safety improvement service campaign to replace the seat belt buckle assembly without charge.owners can contact chrysler at 1-800-853-1403.
- Campaign:
- 99V340000 on 12/21/1999
- Component:
- Service brakes, hydraulic:foundation components:disc:rotor
- Manufactured:
- 02/27/1991 - 07/06/1995
- Affected:
- 334,047
- Defect:
- Vehicle description: passenger and multi-purpose vehicles originally sold or currently registered in the states of connecticut, illinois, indiana, maine, maryland, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, or wisconsin, and the district of columbia. the front disc brake rotors can experience severe corrosion if operated for an extensive period in the "salt belt." if the rotors are not replaced, the corrosion can eventually compromise the structural integrity of the stamped steel center hub section of the rotor.
- Consequence:
- The reduced strength can allow the cast iron wear surface to separate from the hub, reducing the brake effectiveness of the vehicle.
- Correction:
- Dealers will replace these rotors with rotors that are coated with a corrosion protection.
- Notes:
- Owner notification began december 20, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V053000 on 02/14/2002
- Component:
- Power train:automatic transmission:lever and linkage:floor shift
- Manufactured:
- 05/31/1992 - 05/30/1998
- Affected:
- 1,620,000
- Defect:
- On certain sport utility vehicles, if a driver has not placed the shifter lever fully into the "park" position and leaves the vehicle running, the vehicle may unexpectedly move rearward after seeming to be stable.
- Consequence:
- Inadvertent movement of the vehicle could result in a crash.
- Correction:
- Dealers will install a secondary detent system to the floor shifter assembly. daimlerchrysler sent interim notices to owners concerning this problem on march 22, 2002. owner notification began september 23, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
1993 JEEP GRAND WAGONEER TSBs (32)
- Bulletin:
- 241794
- Component:
- 116200 electrical system:ignition:module
- Summary:
- pcm not properly disengaging a/c clutch via the relay also the pcm may not energize the a/c clutch relay. *tw
- Bulletin:
- 090994R
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- oil leak diagnosis of the rear main bearing area. *tw
- Bulletin:
- 240493
- Component:
- 353600 equipment:air conditioner
- Summary:
- automatic temperature control - temperature and blower speed variations. *tw
- Bulletin:
- 050195
- Component:
- 010000 steering
- Summary:
- drift left under hard braking. *tw
- Bulletin:
- 030295
- Component:
- 022000 suspension:rear
- Summary:
- snapping or popping noise in rear suspension. *tw
- Bulletin:
- CH240695A
- Component:
- 353600 equipment:air conditioner
- Summary:
- Unknown
- Bulletin:
- CH030295A
- Component:
- 022100 suspension:rear:springs
- Summary:
- Unknown
- Bulletin:
- CH240895
- Component:
- 353600 equipment:air conditioner
- Summary:
- Unknown
- Bulletin:
- CH231495
- Component:
- 980000 unknown or other
- Summary:
- roof rack rattle or stanchion release button sticking or falling out. *tw
- Bulletin:
- 081695REVA
- Component:
- 180000 vehicle speed control
- Summary:
- bulletin supersedes technical service bulletin 08-16-95, dated apr. 14, 1995. if the vehicle operator **repeatedly** presses and releases the set button with their foot off of the accelerator (a 'lift foot set' to begin speed control oper
- Bulletin:
- 230397
- Component:
- 161000 structure:frame and members
- Summary:
- Difficult to clean light colored "chalky" residue from plastic body components that are molded in black. *tw
- Bulletin:
- 210297
- Component:
- 102000 power train:manual transmission
- Summary:
- A thumping or bumping noise may be heard coming from the transmission tunnel area on acceleration or while driving over bumpy roads. *yc
- Bulletin:
- 241797
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- A revised cowl plenum screen has been released which contains a fine mesh screen to minimize debris from entering the heater a/c housing. *yc
- Bulletin:
- 240298
- Component:
- 353600 equipment:air conditioner
- Summary:
- Service manual procedures to service the heater a/c housing. *yc
- Bulletin:
- 210998
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- A thumping or creaking noise may be heard coming from the transmission tunnel area on acceleration or while driving over bumpy roads. *yc
- Bulletin:
- 081798 REV B
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Subject regarding the airbag on-off switches. *yc
- Bulletin:
- 081798
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Subject regarding airbag on - off switches. *yc
- Bulletin:
- 233599
- Component:
- 220000 seats
- Summary:
- Information on child seat tether anchors. *tt
- Bulletin:
- 98733
- Component:
- 103800 power train:automatic transmission:park/neutral start switch
- Summary:
- Subject on customer satisfaction notification #733--brake pedal shift interlock. *yc
- Bulletin:
- 210297A
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- This bulletin involves transfer case shifter noise. *nlm
- Bulletin:
- 235397
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Concerns with door check roller repair. *nlm
- Bulletin:
- 241197
- Component:
- 353600 equipment:air conditioner
- Summary:
- Concerns with a/c evaporator odor. *nlm
- Bulletin:
- 083799
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles. *tt
- Bulletin:
- 080600
- Component:
- 114000 electrical system:wiring
- Summary:
- This bulletin provides a revised wire splice procedure and related parts. *tt
- Bulletin:
- 230800
- Component:
- 220000 seats
- Summary:
- Subject regarding child seat tether anchors. *tt
- Bulletin:
- 233599REVA
- Component:
- 162000 structure:body
- Summary:
- Subject on the child seat tether anchors. *mjs
- Bulletin:
- 082700
- Component:
- 140000 air bags
- Summary:
- Subject regarding non-deployed airbag handling procedures. *tt
- Bulletin:
- 2300800B
- Component:
- 220000 seats
- Summary:
- Subject regarding child seat tether anchors. *tt
- Bulletin:
- 0800600REV
- Component:
- 110000 electrical system
- Summary:
- Subject regarding wire splice repairs. *sb
- Bulletin:
- 0801001
- Component:
- 110000 electrical system
- Summary:
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
Home | Privacy