1999 JEEP WRANGLER Recalls (5)
- Campaign:
- 99V117000 on 05/11/1999
- Component:
- Unknown or other
- Manufactured:
- 09/30/1998 - 10/14/1998
- Affected:
- 1,989
- Defect:
- Vehicle description: sport utility vehicles. the left side and right side instrument panel wiring ground attachment screws could loosen over time.
- Consequence:
- If the left side screw loosens, the instrument panel gauges may not function when the headlamps are turned on. if the right side screw loosens, the defroster blower motor may not function.
- Correction:
- Dealers will remove the ground screws, drill a new pilot hole adjacent to the original hole, and the screws will be reinstalled in the new holes.
- Notes:
- Owner notification began may 31, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04E041000 on 06/07/2004
- Component:
- Equipment
- Affected:
- 80
- Defect:
- Bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.
- Consequence:
- Should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.
- Correction:
- Bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06E011000 on 01/31/2006
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Affected:
- 7,291
- Defect:
- Certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.
- Consequence:
- In the presence of an ignition source, a fuel leak could result in a fire.
- Correction:
- Airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.
- Notes:
- This recall only pertains to aftermarket airtex electric fuel pumps and has no relation to any original equipment installed on jeep grand cherokee, cherokee, wrangler, or dodge dakota vehicles manufactured by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E022000 on 03/12/2006
- Component:
- Service brakes, hydraulic
- Affected:
- 7,440
- Defect:
- Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.
- Consequence:
- Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.
- Correction:
- Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.
- Notes:
- This recall only pertains to aftermarket napa, raybestos, ac delco, aimco, carquest, and bendix brake hydraulic master cylinders and has no relation to any original equipment installed on daimlerchrysler or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E026000 on 03/22/2006
- Component:
- Exterior lighting
- Affected:
- 61,944
- Defect:
- Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
- Correction:
- Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
- Notes:
- This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1999 JEEP WRANGLER TSBs (54)
- Bulletin:
- 050398
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Exhibiting minor brake pedal pulstion which may be caused by rough disc rotors. *ak
- Bulletin:
- 210998
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- A thumping or creaking noise may be heard coming from the transmission tunnel area on acceleration or while driving over bumpy roads. *yc
- Bulletin:
- 250298
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding i/m ( inspection maintenance ) testing - obd ii "carb" readiness monitor information. *yc
- Bulletin:
- 234598
- Component:
- 980000 unknown or other
- Summary:
- Approval of using of in- transit protective film. on all vehicles at all assembly plants. *ak
- Bulletin:
- 084298
- Component:
- 116000 electrical system:ignition
- Summary:
- Subject regarding ignition off draw fuse location. *yc
- Bulletin:
- 110798
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Outer exhaust manifold studs may fatigue/break. *ak
- Bulletin:
- 183598
- Component:
- 116000 electrical system:ignition
- Summary:
- Exhibiting mil illumination with dtc $ 12 (p0443) - evaporative purge solenoid circuit failure, can be caused by electrical noise generated through the ignition switch. *ak
- Bulletin:
- 183698
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles may exhibit an idle undershoot or die out during engine starting and may be caused by iac lost steps. *ak
- Bulletin:
- 183798
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- some consumers that inadvertently flood their engines during starting may try to perform a clear flood procedure to help start their vehicles. *ak
- Bulletin:
- 184398
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit an engine sag when the a/c compressor cycles. *yc
- Bulletin:
- 184698
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit an idle undershoot or driveway die out when the transmission is placed from park or neutral into drive or reverse. *ak
- Bulletin:
- 184098
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit high idle rpm during deceleration and/ or parking lot maneuvers when the engine coolant temperature is greater than 103 c (217 f). *yc
- Bulletin:
- 184198
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit an idle undershoot condition whil ethe vehicle is slowly moving at 1-2 mph in low range four wheel drive with the throttle closed. *yc
- Bulletin:
- 081798
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Subject regarding airbag on - off switches. *yc
- Bulletin:
- 9966
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject on kinked transmission cooler flex line. *yc
- Bulletin:
- 230999
- Component:
- 162000 structure:body
- Summary:
- Subject on water leak diagnostic / repair procedures. *tt
- Bulletin:
- 080799
- Component:
- 110000 electrical system
- Summary:
- Information regarding power distribution center (pdc) service. *tt
- Bulletin:
- 80618062
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Emissions recalls 8061 and 8062 regardig spark plug replacement. *tt
- Bulletin:
- 180799
- Component:
- 980000 unknown or other
- Summary:
- Exhibiting erroneous malfunction indicator lamp illumination with diagnostic trouble code $a8 (p1763) governor pressure sensor volts too high. *tt
- Bulletin:
- 210899
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles exhibiting buzz, whining, or moaning like noise from cold transmission when reverse gear is selected. *tt
- Bulletin:
- 9916A
- Component:
- 354600 equipment:mechanical:wrecker and wheel lift devices
- Summary:
- Service action , tj missing tow hooks. *tt
- Bulletin:
- 9916
- Component:
- 354600 equipment:mechanical:wrecker and wheel lift devices
- Summary:
- Service action regarding missing tow hooks. *tt
- Bulletin:
- 180999
- Component:
- 110000 electrical system
- Summary:
- Information pertaining to common diagnostic trouble codes caused by an open fuse. *tt
- Bulletin:
- 081599
- Component:
- 110000 electrical system
- Summary:
- Some vehicles may exhibit an erratic, intermittent cluster operation / intermittent air bag warning light. *tt
- Bulletin:
- 081499
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Conditions with vehicle start and stall or vehicle no-start. *tt
- Bulletin:
- 181299
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This bulletin explains the operation and application of the leak detection pump (ldp) monitor test. *tt
- Bulletin:
- 021299
- Component:
- 021000 suspension:front
- Summary:
- This bulletin pertains to front end alignment - adjustable / offset ball joints. *tt
- Bulletin:
- 081698
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on installation of radio transmitting equipment. *ak
- Bulletin:
- 183298
- Component:
- 162000 structure:body
- Summary:
- Subject on flash programming failure recovery. *yc
- Bulletin:
- 182599
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on erroneous engine miss while performing diagnostics with the diagnostic scan tool (drb iii). *tt
- Bulletin:
- 083799
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles. *tt
- Bulletin:
- 180100
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes p1494, p0442 p0455, or p0456. *tt
- Bulletin:
- 080600
- Component:
- 114000 electrical system:wiring
- Summary:
- This bulletin provides a revised wire splice procedure and related parts. *tt
- Bulletin:
- 233999
- Component:
- 162000 structure:body
- Summary:
- Subject on vehicles experiencing solft top windows which appear foggy or hazy. *mjs
- Bulletin:
- 234199
- Component:
- 162000 structure:body
- Summary:
- Information regarding the improved door weather strip. *mjs
- Bulletin:
- 242199
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Vehicles may experience water dripping from the bottom of the evaporator drain tube and enter the passenger compartment causing wet carpet or water on the passenger compartment floor. *mjs
- Bulletin:
- 082700
- Component:
- 140000 air bags
- Summary:
- Subject regarding non-deployed airbag handling procedures. *tt
- Bulletin:
- 0800600REV
- Component:
- 110000 electrical system
- Summary:
- Subject regarding wire splice repairs. *sb
- Bulletin:
- 0801001
- Component:
- 110000 electrical system
- Summary:
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
- Bulletin:
- 1801201
- Component:
- 350000 equipment
- Summary:
- Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
- Bulletin:
- 2500401
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding additional diagnostic for diagnostic trouble codes caused by an evaporative system leak. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 2401201
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Customers may complain that the hvac drain water leaks under passenger side carpet. *tt
- Bulletin:
- 2302501
- Component:
- 162000 structure:body
- Summary:
- Soft top zipper cleaner and lubricant - for difficult to operate window zippers. *tt
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
- Bulletin:
- 2100903
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission diagnostic teardown procedure. various models including the 2004 ram truck, durango, sebring convertible, cherokee, vision, neon, and voyager. *tt *sc
- Bulletin:
- 2400703
- Component:
- 353600 equipment:air conditioner
- Summary:
- Hvac drive water leaks under passenger side front carpet. *tt
- Bulletin:
- 0900303
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 4.0l multiple cylinder misfire. *tt
- Bulletin:
- 0901004
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Dirt and debris accumulation at rear main seal. *tt
- Bulletin:
- 2300504
- Component:
- 162000 structure:body
- Summary:
- Soft top zipper cleaner and lubricant - for difficult to operate window zippers. *tt
- Bulletin:
- 0801505
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Powertrain control module initialization. *sc
- Bulletin:
- 2401305
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning (a/c) cooling coil odor. *tt
- Bulletin:
- 2301006
- Component:
- 162000 structure:body
- Summary:
- Primary door weatherstrip water leak at a-pillar belt line. *tt
- Bulletin:
- 1900306
- Component:
- 010000 steering
- Summary:
- Steering shimmy. *tt
Home | Privacy