2004 FREIGHTLINER FREIGHTLINER Recall
- Campaign:
- 05V284000 on 06/16/2005
- Component:
- Suspension
- Affected:
- 634
- Defect:
- Certain freightliner trucks and thomas school buses equipped with holland/neway air suspension systems, a transverse beam casting may fracture under normal loads. if a casting breaks when the vehicle is traveling on a roadway there is the potential for pieces of the casting to become projectiles and the suspension's transverse beam may drop down low enough to contact the road surface.
- Consequence:
- This will cause sparks that could potentially ignite and cause a fire.
- Correction:
- Dealers will inspect and replace the defective transverse beam assemblies. the recall began for thomas built owners on february 10, 2006; and for freightliner owners on april 14, 2006. owners may contact freightliner at 1-800-547-0712.
- Notes:
- Freightliner recall no.fl-453.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
2004 FREIGHTLINER FREIGHTLINER TSBs (5)
- Bulletin:
- 06M-6
- Component:
- 980000 unknown or other
- Summary:
- Detroit diesel corporation (ddc) has determined that additional support brackets will need to be attached to the existing lifter bracket in order to reinforce the lifter bracket/water pump housing assembly. mbe 4000 epa 04 engines equippe
- Bulletin:
- SB-32-10
- Component:
- 022132 suspension:rear:springs:air suspension system:springs/bags
- Summary:
- Freightliner llc: troubleshooting for a misalignment of the suspension air springs. *rm
- Bulletin:
- FL-646-A
- Component:
- 110000 electrical system
- Summary:
- Freightliner: an improperly functioning on board emission related diagnostic system is on some bus chassis and is emitting excessive pollutants, violating federal emission standards and malfunction indicator lamp (mil) fails to illuminate.
- Bulletin:
- TSB T2007-01 REV
- Component:
- 114000 electrical system:wiring
- Summary:
- Intelligent life interlock system (ilis) the shift lock status led (amber) flashes and the sfhifter does not lock with the park brake on and /or the lift door open. this will only occur if the vehicle battery voltage drops below 7.5 volts d
- Bulletin:
- 954-12
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- 954-12 installation of the fuel injector.pdf
Home | Privacy