2012 VOLKSWAGEN GOLF Recalls (5)
- Campaign:
- 11V490000 on 10/02/2011
- Component:
- Fuel system, diesel
- Affected:
- 168,275
- Defect:
- Volkswagen is recalling certain model 2009-2012 jetta and jetta sportwagen vehicles, manufactured from may 2008 through september 2011, model year 2010-2012 volkswagen golf vehicles, manufactured from may 2009 through september 2011, and model year 2010-2012 audi a3 vehicles, manufactured from september 2009 through september 2011, that are equipped with a 2.0l tdi common rail diesel engine/clean diesel engine. the fuel injection pulses could coincide with the natural frequency of the injector line #2, in specific load and rpm conditions. this resonance creates additional stress in the fuel line.
- Consequence:
- Due to the resonance condition, injector line number 2 could develop small cracks which could lead to fuel leakage. leaking fuel in the presence of an ignition source, may lead to a fire.
- Correction:
- Volkswagen will install an improved fuel injector line for the number 2 cylinder on certain vehicles and will install vibration dampers on all of the injector lines. volkswagen and audi will notify owners to have the vehicles repaired free of charge. the safety recall is expected to begin during november 2011. owners may contact volkswagen at 1-800-822-8987.
- Notes:
- Volkswagen recall campaign number is 23j9/v5 & 23j8/k5.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 15V483000 on 08/03/2015
- Component:
- Air bags:frontal
- Manufactured:
- 05/25/2010 - 09/29/2013
- Affected:
- 415,825
- Defect:
- Volkswagen group of america, inc. (volkswagen) is recalling certain model year 2010-2014 volkswagen cc, and passat, 2010-2013 eos, 2011-2014 golf, gti, jetta, and tiguan, and 2012-2014 jetta sportwagen vehicles. in the affected vehicles, debris may contaminate the air bag clock spring, a spiral wound, flat cable that keeps the air bag powered while the steering wheel is being turned. this contamination may tear the cable and result in a loss of electrical connection to the driver's frontal air bag.
- Consequence:
- A loss of electrical connection to the driver's frontal air bag will prevent the air bag from deploying in the event of a vehicle crash, increasing the risk of injury.
- Correction:
- Volkswagen will notify owners, and dealers will install a protective cover over the steering wheel clock spring if the air bag light is off. if the airbag light is on and the steering wheel clock spring requires replacement, dealers will install a new steering wheel clock spring. these repairs will be performed free of charge. the recall began on january 15, 2016. owners may contact volkswagen customer service at 1-800-822-8987.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 16V078000 on 02/09/2016
- Component:
- Air bags:frontal:driver side inflator module
- Affected:
- 659,493
- Defect:
- Volkswagen group of america, inc. (volkswagen) is recalling certain model year 2010-2014 golf, 2007-2010 passat sedans and wagon, 2012-2014 passat sedan and eos, 2009-2014 cc, 2009-2012 audi q5, 2010-2012 s5 cabriolet and 2010-2012 audi a5 cabriolet vehicles. upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
- Consequence:
- In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
- Correction:
- Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. volkswagen issued an interim notification to owners on april 12, 2016, and will send a second notification when parts are available. volkswagen will notify owners again once parts are available. volkswagen owners may contact volkswagen customer service at 1-800-893-5298. audi owners may contact audi customer service at 1-800-253-2834.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 18V148000 on 03/07/2018
- Component:
- Air bags:frontal:driver side inflator module
- Manufactured:
- 03/16/2009 - 10/29/2013
- Affected:
- 363,713
- Defect:
- Volkswagen group of america, inc. (volkswagen) is recalling certain 2009-2014 volkswagen cc, 2010-2014 golf, 2010-2014 eos, 2007-2010 passat sedan and wagon, and 2012-2014 passat vehicles. upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
- Consequence:
- In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
- Correction:
- Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. the recall began march 16, 2018. owners may contact volkswagen customer service at 1-800-893-5298. volkswagen's number for this recall is 69q9. note: this recall partially supersedes recall 16v-078.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 18V329000 on 05/21/2018
- Component:
- Unknown or other
- Manufactured:
- 03/01/2011 - 10/26/2015
- Affected:
- 252
- Defect:
- Volkswagen group of america, inc. (volkswagen) is recalling certain 2012-2016 eos, 2012 passat, 2012-2016 cc, 2015 e-golf, 2011-2015 touareg, 2012-2015 tiguan, and 2011-2016 golf and 2011-2013 gti vehicles. modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
- Consequence:
- If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
- Correction:
- Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or volkswagen will repurchase them if necessary, free of charge. interim notices informing owners of the safety risk were mailed july 13, 2018. owners will receive a second notice when the remedy becomes available. owners may contact volkswagen customer service at 1-800-893-5298.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2012 VOLKSWAGEN GOLF TSBs (357)
- Bulletin:
- TB-21-11-08
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: in some vehicles, the warning light for engine may be on and the engine power has failed. *pe
- Bulletin:
- TB-37-12-02
- Component:
- 102000 power train:manual transmission
- Summary:
- Volkswagen: while driving approximately 55 to 65mph, a whinning or whistle noise is heard. the shifter cable may transmit noise, which may come from transmission counter gear, into passenger compartment. *pe
- Bulletin:
- 2028609
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: update programming for engine control module and transmission control module, slight hesitation concerns. also included model golf wagon model year 2012. *js
- Bulletin:
- V-691202
- Component:
- 140000 air bags
- Summary:
- Volkswagen: airbag warning lamp illuminated in instrument cluster, dtc b101614 stored in airbag control module. airbag lam in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp. *js updated 04/
- Bulletin:
- TB-15-12-01
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: all models experience the timing chain slipping, rattling noises of the engine after starting, and engine fails to start. 2008-13 all models. *pe
- Bulletin:
- TB-69-12-02
- Component:
- 110000 electrical system
- Summary:
- Volkswagen: due to a loose or unfastened connector for passenger air bag, the airbag warning lamp may illuminate in instrument panel. models 2010-2013 golf, gti, jetta sportwagen, jetta sedan. *pe
- Bulletin:
- 151204
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: camshaft adjustment valve 1-n205-diagnosis. one or more specific fault codes may be stored in the ecm fault memory. *js
- Bulletin:
- 171206
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: possible oil leak from oil filter housing. manufacturing debris found in the oil filter housing may prevent a proper seal with the filter flange, resulting in an oil leak. *js
- Bulletin:
- V201203
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Volkswagen:evaporative (evap) emission system, diagnostic trouble code diagnosis. revised procedure developed to test evap system without fuel cap. *js
- Bulletin:
- 241208
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Volkswagen: intake manifold restriction check. mil-on and 1 or more of the following diagnostic codes may be stored in ecm fault memory. *js
- Bulletin:
- TB-01-12-36
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: depending on the driving conditions, a slight hesitation, related to concerns of dsg in vehicles ,with current ecm/tcm programming, will have an improved software for the ecm/tcm to address concerns and slight hesitation. mod
- Bulletin:
- TT-57-11-08
- Component:
- 016000 steering:electric power assist system
- Summary:
- Volkswagen: if electronic steering column lock was replaced or updated, would cause the remote keyless entry failure to lock doors or arm alarm, but will unlock doors. models 2011-2013 golf, gti, jetta tiguan, passat, beetle.
- Bulletin:
- TB-19-13-01
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Volkswagen: it is a normal occurrence for the electric coolant fans to continue to run after the ignition is switched off. *js
- Bulletin:
- 48-13-02
- Component:
- 010000 steering
- Summary:
- Volkswagen: some vehicles may exhibit poor power steering assistance. dtcs may be stored in power steering control module j500. alsoincluded model jetta sportwagen model year 2010-2012. *js updated 12/4/13. *pe
- Bulletin:
- 01-13-14
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: some vehicles may experience a misfire and/or reduced engine performance. *js
- Bulletin:
- TT-45-09-03
- Component:
- 010000 steering
- Summary:
- Volkswagen: steering rack. after replacing the steering rack the fault code 01309 008 is set in abs/esp module. also included model gti my 2013, model tiguan my 2005-2007, model rabbit my 2005/2011-2013, model eos my 2005/2013, model cc my
- Bulletin:
- TB-27-13-01
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: due to accessory drive belt being damaged or missing, the charging system is inoperative or malfunction, and noise is coming from engine compartment. model 2012-2014 all vehicles except routan, touareg hybrid, jetta hybrid.
- Bulletin:
- TB-20-13-05
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Volkswagen: on some vehicles, low fuel stored in ecm pressure, engine would crank but not start long periods without driving, may run rough and/or mil on. all models 2008-2013. *pe
- Bulletin:
- TB-20-13-06
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: activated charcoal filter system, solenoid valve and performing gff function test a vacuum check on canister purge valve n80 are essential to diagnose proper operation. model 2009-14 all but routan.
- Bulletin:
- TSB-21-13-01
- Component:
- 060000 engine and engine cooling
- Summary:
- Volkswagen: during cold weather, engine fails to start, after standing, and if moisture, from intake air, condenses, would freeze and block intake air system, in charge air cooler. *pe
- Bulletin:
- TB-69-14-02
- Component:
- 140000 air bags
- Summary:
- Volkswagen: airbag warning light was illuminated indicating a front side airbag pressure sensor interruption/short to b+. the dtcs b101715 and b103615. *js
- Bulletin:
- 19J5
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Some customers of 2012 and 2013 model year vehicles have noise in the engine compartment. *lj
- Bulletin:
- 2029767
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Airbag warning lamp may illuminate due to unfastened connector. *lj
- Bulletin:
- TB-21-14-03
- Component:
- 060000 engine (pws)
- Summary:
- Volkswagen: some vehicles fail to have any power or the check engine warning light is on. *pe
- Bulletin:
- PRI B
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Volkswagen: some volkswagen vehicles with 2.0 tfsi engines will have the intake manifold and fuel injectors warranty extended. 7/23/15 *ta
- Bulletin:
- TB-23-15-03
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Volkswagen: vehicle is rough running, fails to start and malfunction indicator lamp (mil) be on and after checking components and no root cause is found, need to check high pressure fuel pump for metallic particles. model 2009-12 golf jet
- Bulletin:
- ESA-23O6
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Volkswagen: tsb contains an owner notification letter. select document search button below. to ensure emissions of tailpipe is optimized and efficiently operating, the engine management software was improve due to an updated ecm software
- Bulletin:
- 2029514
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 19J5
- Component:
- 092100 fuel system, other:delivery:fuel pump
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 19J5
- Component:
- 060000 engine and engine cooling
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2012855
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 40-13-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 44-13-03
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 44-13-04
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 44-13-04
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 57-12-06
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2034012
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT57-11-11
- Component:
- 162320 structure:body:door/window:emergency exit
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-1212
- Component:
- 103000 power train:automatic transmission
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2031583
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2029514
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2032116
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2029514
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 17-12-03
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2023248
- Component:
- 160000 structure
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2028609
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- V231505 2041063
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 01-15-07
- Component:
- 060000 engine (pws)
- Summary:
- Correction to fault code
- Bulletin:
- TT 01-15-07
- Component:
- 060000 engine (pws)
- Summary:
- Control module faulty
- Bulletin:
- V011609_2034898
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- To update golf (exchange parts) time units due to saga/elsa updates 6/13/16. mil on, dtc p0401 exhaust gas recirculation flow insufficient stored in ecm fault memory, could be accompanied with fault p2463 dpf soot accumulation.
- Bulletin:
- V501606_2011761
- Component:
- 162200 structure:body:bumpers
- Summary:
- To update claim processing statement.
- Bulletin:
- V511601_2038990
- Component:
- 161000 structure:frame and members
- Summary:
- To update claim process statement. rocker panel - front fender ' corrosion corrosion on contact surfaces of the front fender to rocker panel (side member).
- Bulletin:
- DEALER LETTER -
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This dealer letter gives an update on the current emissions issues with regards to 2.0l tdi vehicles.
- Bulletin:
- TT 571004
- Component:
- 110000 electrical system
- Summary:
- Update to model year applicability.
- Bulletin:
- V511603_2038990
- Component:
- 162000 structure:body
- Summary:
- Better define corrosion damage and location covered by this technical bulletin.
- Bulletin:
- V871616_2044165
- Component:
- 353600 equipment:air conditioner
- Summary:
- To update causal part numbers in warranty table and update model year applicability.
- Bulletin:
- V011608_2034898
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- To update warranty labor operations due to elsa updates, and to include an additional parts table for replacing a one piece system with a two piece system.
- Bulletin:
- V231604_2041063
- Component:
- 060000 engine (pws)
- Summary:
- Updated technical bulletin to add injector seal plate to parts table.
- Bulletin:
- V871616_2044165
- Component:
- 353600 equipment:air conditioner
- Summary:
- To update causal part numbers in warranty table and update model year applicability.
- Bulletin:
- DEALER LETTER -
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This dealer letter gives an update on the current emissions issues with regards to 2.0l tdi vehicles.
- Bulletin:
- V011613_2033805
- Component:
- 060000 engine (pws)
- Summary:
- "engine, misfire diagnostic aid the mil is flashing or illuminated."
- Bulletin:
- TT 97-14-02
- Component:
- 110000 electrical system
- Summary:
- Tech tip denoting potential for damage of the data link connector when using after market plug in devices or scan tools and subsequent diagnostic direction.
- Bulletin:
- VWS-15-01
- Component:
- 060000 engine (pws)
- Summary:
- This communication informs dealers of the warranty claim coding for 30-day inventory maintenances on 2.0l and 3.0l tdi vehicles.
- Bulletin:
- TT 13-16-01
- Component:
- 103000 power train:automatic transmission
- Summary:
- Reminder to follow the correct repair procedure of pilot bearing replacement, when removing and re-installing the dsg transmission
- Bulletin:
- TT 901204_203072
- Component:
- 117000 digital instrument panel
- Summary:
- Instructions to manually set service internal maximum values after instrument cluster replacement, to prevent false messages to the customer.
- Bulletin:
- TDI EMISSIONS SE
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This communication informs of the tdi emissions settlement agreement with regards to 2.0l tdi vehicles.
- Bulletin:
- TT 901204_203072
- Component:
- 110000 electrical system
- Summary:
- Instructions to manually set service internal maximum values after instrument cluster replacement, to prevent false messages to the customer.
- Bulletin:
- V941601_2011521
- Component:
- 120000 lighting (pws)
- Summary:
- Update technical bulletin to include all 2017 models
- Bulletin:
- V011606_2014603
- Component:
- 110000 electrical system
- Summary:
- Update technical bulletin to include all models for 2015, 2016, 2017 model year applicability.
- Bulletin:
- DEALER LETTER -
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This dealer letter gives an update on the current emissions issues with regards to 2.0l tdi vehicles.
- Bulletin:
- V001706_2033708
- Component:
- 160000 structure
- Summary:
- Update tb to include model year 2016 & 2017 applicability
- Bulletin:
- V231703_2041063
- Component:
- 080000 fuel system, diesel
- Summary:
- Update fuel sampling requirement.
- Bulletin:
- V271701_2033978
- Component:
- 060000 engine (pws)
- Summary:
- Update existing technical bulletin to include model year 2017 applicability.
- Bulletin:
- TT 00-14-02
- Component:
- 070000 fuel system, gasoline
- Summary:
- Tech tips (adapting injector quantity adjustment correction values (ima/iva)): when replacing or adapting fuel injectors, if there is no guided functions test plan, utilize this documents procedure
- Bulletin:
- TT 44-13-04
- Component:
- 010000 steering
- Summary:
- Tech tips (steering wheel off center): this tech tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel
- Bulletin:
- TT 50-14-01
- Component:
- 190000 tires
- Summary:
- Tech tips (all vehicles-tire dressing for vehicle detailing): the use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. this document informs that the use of non-water based products wil
- Bulletin:
- V941403 2011521
- Component:
- 120000 exterior lighting
- Summary:
- Technical bulletin (exterior lights, moisture accumulation): this document informs of the condensation and or water droplets visible on inside of exterior light lenses. the document also informs how to service the issue.
- Bulletin:
- TT 20-13-02
- Component:
- 070000 fuel system, gasoline
- Summary:
- Tech tips (fuel line connections): be aware that fuel lines are color coded on vehicles with return fuel pressure lines. the black line is for fuel pressure supply and the blue line is for fuel pressure return.
- Bulletin:
- TT 23-14-01
- Component:
- 070000 fuel system, gasoline
- Summary:
- Tech tips (2009-2014 all tdi (2.0l, 3.0l) common rail models passat, golf, jetta, jetta sportwagen, touareg adapting injector quantity adjustment correction values (ima/iva)): this document informs when replacing or adapting fuel injectors
- Bulletin:
- TT 32-14-01
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Tech tips (torque converter/flywheel/flexplate installation): incorrect torque converter or flywheel/flexplate installation can result in transmission damage. when installing an engine, flywheel or transmission, please follow the installat
- Bulletin:
- TT 44-14-02
- Component:
- 046300 service brakes, air:antilock:wheel speed sensor
- Summary:
- Tech tips (abs/tpms light is on due to wheel speed sensor fault as a result of the front wheel bearing / wheel speed sensor swapping issue): this document informs of the damage caused from swapping the speed sensors left to right (or vice v
- Bulletin:
- V001406 2015780
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin (pdi - vehicle inspection, protection removal and detailing): this document informs on the service a vehicle shouold received when it has successfully reached a dealership. ? inspecting vehicle for damage (to be compl
- Bulletin:
- V301402 2031366
- Component:
- 101000 power train:clutch assembly
- Summary:
- Technical bulletin (slave cylinder - clutch pedal operation diagnosis): customer may comment: ? complaints on clutch system. ? after pressing the clutch pedal, it remains on the floor. due to mis-diagnosis of clutch systems, and to prev
- Bulletin:
- V281403 2037386
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (glow plug pressure sensor faults): when diagnosing mil on with glow plug pressure sensor dtc?s it important to perform diagnosis prior to replacing the glow plug. this document informs on the procedure to service this
- Bulletin:
- V011414 2035464
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (cylinder contribution / balance fault issues): the diagnostic strategy for zero fuel calibration is too sensitive. the production solution for this issue was new software being implemented into production. this docum
- Bulletin:
- Customer Letter
- Component:
- 080000 fuel system, diesel
- Summary:
- 2009-2015 model year volkswagen tdi® clean diesel vehicles registered in minnesota engine codes cbea, cjaa, ckra, cata, cnrb using biodiesel blend fuels: biodiesel is a domestically produced, clean-burning and renewable partial substitute
- Bulletin:
- Dealer Letter -
- Component:
- 080000 fuel system, diesel
- Summary:
- Upcoming communication to owners of 2009-2015 my volkswagen tdi clean diesel engine vehicles registered in the state of minnesota engine codes cbea, cjaa, ckra, cata, cnrb using biodiesel fuel blends: this document informs that due to new
- Bulletin:
- V011419 2035464
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (cylinder contribution/balance faults): this document informs that the diagnostic strategy for zero fuel calibration was too sensitive. the production solution for this issue was software implemented into production. th
- Bulletin:
- TT 87-14-01
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tech tips (ac compressor replacement, refrigerant circuit flushing requirement): this document informs when replacing the air conditioning compressor it is necessary to flush the entire system to remove all the pag oil. replacement ac comp
- Bulletin:
- TT 57-10-11
- Component:
- 110000 electrical system
- Summary:
- Tech tips (comfort module (j393) or bcm (j519) replacement): this document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched off. this can be accomplished by selec
- Bulletin:
- TT 45-09-04
- Component:
- 010000 steering
- Summary:
- Tech tips (2009-2015 jetta, eos, rabbit, golf, gti, passat, cc, and tiguan equipped with electromechanical power steering ? g85 location identification tip): ths document informs of the location of the g85 steering sensor. the sensors expe
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- V871409 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (air conditioning, cleaning of the refrigerant circuit): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ
- Bulletin:
- V261403 2028415
- Component:
- 042500 service brakes, air:supply:low pressure warning
- Summary:
- Technical bulletin (secondary air injection system air flow/pressure): this document informs the secondary air pressure sensor may be contaminated by foreign particles during secondary air injection. the production solution for this issue
- Bulletin:
- V171404 2012855
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (engine oils which meet volkswagen oil quality standard): this document informs of a sample list of products generally available in the north american market that meet the volkswagen oil quality standard
- Bulletin:
- V011421 2034898
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Technical bulletin (exhaust gas recirculation flow insufficient, and soot accumulation issues): this document informs of high soot loads prior to regeneration which can cause possible restrictions in the egr filter. the production soluti
- Bulletin:
- 69M8 and 69M9 pa
- Component:
- 140000 air bags
- Summary:
- This communication informs the dealers of details on the takata parts allocation.
- Bulletin:
- V011701_2034898
- Component:
- 350000 equipment
- Summary:
- Update parts table.
- Bulletin:
- TT451101ss3_2030
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update tech tip to include model year 2017 applicability.
- Bulletin:
- TDI IN-FORM Rewa
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tdi in-form rewards announcement
- Bulletin:
- Elsa Newsletter
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Reminder that odis service v3.0.0 is now available for installation, and that it is mandatory on all diagnostic devices used on vehicles covered by the new vehicle warranty. with the release of v3.0.0. installation dvds are no longer used.
- Bulletin:
- Elsa Newsletter
- Component:
- 200000 wheels
- Summary:
- Summary of technical bulletin to include additional model and model year applicability. corrosion, front fenders, at upper wheel opening (u.s. only)
- Bulletin:
- V501601 2011761
- Component:
- 162000 structure:body
- Summary:
- Information on areas surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. also gives examples of how to calculate cost to repair or replace
- Bulletin:
- V011601 2034898
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 01 16 01 january 8, 2016 2034898 supersedes technical bulletin v011526 dated november 5, 2015 to update warranty labor operations due to elsa updates.
- Bulletin:
- V501602 2011761
- Component:
- 162000 structure:body
- Summary:
- Document refers to surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. it gives examples on where to check for repair coverage from warranties, fixing possible issues, and how to docu
- Bulletin:
- V401601 2043146
- Component:
- 021300 suspension:front:shock absorber
- Summary:
- Technical bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak. document contains examples of strut or shock absorber leak assessments
- Bulletin:
- V371601 2033975
- Component:
- 103000 power train:automatic transmission
- Summary:
- This document was created in response to multiple dealership inquires about aftermarket universal (one fluid fits all) automatic transmission fluids and transmission flushing, volkswagen group of america, volkswagen canada have prepared the
- Bulletin:
- V341601 2034406
- Component:
- 101000 power train:clutch assembly
- Summary:
- Discusses possible causes of customer concern customer states there is a noise from the clutch, transmission or driveline components under varying driving conditions with varying sound levels
- Bulletin:
- V271601 2033978
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Document discusses possible needs for generator replacement, charging system inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing. document also discusses where to find warranty information for co
- Bulletin:
- V191601 2022549
- Component:
- 060000 engine and engine cooling
- Summary:
- Tech bullentin concerning electric coolant fans that continue to run after ignition is switched off
- Bulletin:
- V011602 2014815
- Component:
- 070000 fuel system, gasoline
- Summary:
- Technical tips on what to do if improper gasoline has been added to the vehicle.
- Bulletin:
- V001602 2033846
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Fuel additive to help prevent sporadic misfire faults a volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves.
- Bulletin:
- V001601 2034407
- Component:
- 350000 equipment
- Summary:
- Document informs meaning of service numbers to discribe issuse with if the customer is experiencing clutch related issues and the concern is found to be within the clutch components if the customer is experiencing manual gearbox relat
- Bulletin:
- TT 97-14-02ss1
- Component:
- 110000 electrical system
- Summary:
- Tech tips damage to data link connector (dlc) from aftermarket devices (cannot communicate with vehicle obd system)
- Bulletin:
- V851601 2041609
- Component:
- 350000 equipment
- Summary:
- Technical bulletin concerning the fresh air blower being inoperative. it discusses possible issues and how to service these issues. it also refers to where to find warranty information for service coverage
- Bulletin:
- V501604 2014370
- Component:
- 162000 structure:body
- Summary:
- Technical bulletin about paint finish, reducing swirl marks and fine scratches new vehicles (prior to retail delivery) with swirl marks and or fine scratches from polishing or cleaning. the document also have infromation about where to fi
- Bulletin:
- TT 45-06-122
- Component:
- 200000 wheels
- Summary:
- Tech tips (active wheel speed sensor diagnosis): this document informs of a procedure to diagnose active wheel speed sensor complaints.
- Bulletin:
- V921501 2037322
- Component:
- 350000 equipment
- Summary:
- Technical bulletin: this document concerns the sensitivity of the washer solvent level sensor (g33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. the operation of the
- Bulletin:
- TT 27-13-01
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Tech tips: generator charging concern diagnosis tip - one way clutch pulley testing
- Bulletin:
- TT 57-10-15
- Component:
- 110000 electrical system
- Summary:
- Tech tips: vehicles with immobilizer with download/discharge? new key will not program
- Bulletin:
- V271501 2011894
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin: battery, testing and charging using midtronics vas6161, mcr340v, incharge 940, or grx3000vas charger
- Bulletin:
- TT 90-11-07
- Component:
- 117000 digital instrument panel
- Summary:
- Tech tips: instrument cluster illumination
- Bulletin:
- TT 45-11-01
- Component:
- 140000 air bags
- Summary:
- Tech tips: covers concerns with both the anti-lock brake (abs) and airbag systems working together
- Bulletin:
- V511501 2038990
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin (rocker panel - front fender ? corrosion ): document discusses diagnosis, and potential remedy of issue. the document also has example claim forms for repears. the diagnosis codes for checking warranty coverage for servi
- Bulletin:
- V501501 2011761
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin corrosion, front fenders, at upper wheel opening (u.s. only) ): document discusses diagnosis, and potential remedy of issue. the diagnosis codes for checking warranty coverage for servicing the vehicle are also available
- Bulletin:
- V211502 2025464
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (frozen charge air cooler ? engine will not start): document discusses diagnosis codes necessary to diagnosis, and potential remedy of engine issue. the diagnosis codes for checking warranty coverage for servicing the ve
- Bulletin:
- V211501 2026771
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin: discussion on engine issues lacking performance. the document covers diagnosis of the engine and the codes that are meant to describe the issues. how to service the issue is discussed, and where to find warranty informa
- Bulletin:
- V011503 2014815
- Component:
- 070000 fuel system, gasoline
- Summary:
- Discusses the issues associated with using contaiminated gasoline. there are recommendations to use top tier gasoline retailers
- Bulletin:
- V011502 2034046
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin: update programming of ecm for concerns of a bump sensation after coming to a stop. the document contains the update programming procedure software version management unit codes. it also contains information on where to
- Bulletin:
- TT 96-12-07
- Component:
- 356000 equipment adaptive
- Summary:
- Tech tips: equipping vehicles with kessy ? key adaptation tip
- Bulletin:
- V941501 2011521
- Component:
- 120000 exterior lighting
- Summary:
- Technical bulletin: condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document
- Bulletin:
- V661502 2027119
- Component:
- 356000 equipment adaptive
- Summary:
- Technical bulletin: diagnosing with damage on external chrome or aluminum surfaces
- Bulletin:
- V641501 2039887
- Component:
- 162300 structure:body:door
- Summary:
- Technical bulletin (rear door glass inoperative issue diagnosis): the rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move
- Bulletin:
- V271503 2016076
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin: battery, discharged, diagnosis for excessive static current draw
- Bulletin:
- V271502 2033978
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin: the document refers to diagnosing charging systems for issues
- Bulletin:
- V201501 2031426
- Component:
- 070000 fuel system, gasoline
- Summary:
- Technical bulletin (high pressure fuel pump diagnosis): completing the gff high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements.
- Bulletin:
- V011505 2029373
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin: this software update is designed to re-program the ecm (engine control module) with new software. this software update is for slight hesitation related concerns on 2012 model year vehicles
- Bulletin:
- TT 27-15-02
- Component:
- 356000 equipment adaptive
- Summary:
- Tech tips (test plan to calibrate adaptive cruise control sensors will not begin notice): notification that if the test plan to calibrate the adaptive cruise control sensors will not begin, turn off the overhead lights in the shop. the wave
- Bulletin:
- TT 44-13-04
- Component:
- 010000 steering
- Summary:
- Tech tips (steering wheel off center): this tech tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel
- Bulletin:
- TT 23-10-02
- Component:
- 060000 engine (pws)
- Summary:
- Tech tips (common rail tdi ? fuel filter replacement and prime/bleed procedure): this document informs when replacing fuel system components on the common rail tdi engine (including the fuel filter), the fuel system must be primed. the p
- Bulletin:
- TT 20-13-01
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Tech tips (ecm fault p1250 "fuel level too low" will not clear): this document informs to clear static ecm fault p1250 "fuel level too low", add fuel to vehicle and complete a road test of at least 10 miles. simply adding fuel without co
- Bulletin:
- TT 19-13-02
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Tech tips (2.0l ccta/cbfa coolant leak or repeat coolant leak from the water pump area): inspect the water pump for signs of contact with engine oil. engine oil may cause the water pump gasket to swell, which may lead to a coolant leak.
- Bulletin:
- TT 01-14-01
- Component:
- 100000 power train
- Summary:
- Tech tips (lean fuel trim readings): this document informs to recheck the crankcase vacuum at idle. if low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). erase the faults and road test 10
- Bulletin:
- V911409 2031136
- Component:
- 353000 equipment:electrical
- Summary:
- Technical bulletin (update programming rcd-510 radio (premium 8)): this document informs programming contained in software level(s) 0007, 0008, 0009, 0010, 0011, 0012, 0013, 0014, 0015, 0016 for certain rcd-510 radio (premium 8) radios m
- Bulletin:
- V191401 2022549
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (electric coolant fans continue to run after ignition is switched off): this documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignit
- Bulletin:
- V151403 2032173
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (camshaft adjustment valve 1 -n205- diagnosis): completing the gff function test and performing basic settings on the camshaft adjustment valve are essential to diagnose proper operation and to avoid unnecessary replac
- Bulletin:
- V011422 2035464
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (cylinder contribution/balance faults): this document informs that the diagnostic strategy for zero fuel calibration too sensitive. the production solution for this issue was new software implemented. this document dis
- Bulletin:
- V001411 2033708
- Component:
- 160000 structure
- Summary:
- Technical bulletin (removing paint contaminants from exterior paint): this document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint.
- Bulletin:
- Customer Program
- Component:
- 350000 equipment
- Summary:
- This document includes what incentives are included in the volkswagen tdi customer goodwill package.
- Bulletin:
- Revised_Oil_Capa
- Component:
- 060000 engine (pws)
- Summary:
- Job aid ? vw engine oil capacities (gasoline, diesel, hybrid engines)
- Bulletin:
- V871627 2044165
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated to require additional print outs during warranty claiming.
- Bulletin:
- V011528 2033805
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (engine, misfire diagnostic aid): this document informs that multiple components should not be replaced for 1 misfiring cylinder. repeat repairs must be carefully addressed to identify the root cause of the concern. if m
- Bulletin:
- V921503 2037322
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (washer level sensor issues): the sensitivity of the washer solvent level sensor (g33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. the operation
- Bulletin:
- V231510 2041063
- Component:
- 080000 fuel system, diesel
- Summary:
- Technical bulletin (fuel rail/system pressure issues): when diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all gff diagnostic procedures have been performed
- Bulletin:
- On-Car Analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- TT 01-14-01
- Component:
- 070000 fuel system, gasoline
- Summary:
- Tech tips (lean fuel trim readings): this document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced
- Bulletin:
- TT 64-14-02
- Component:
- 138200 visibility:defroster/defogger system:rear window
- Summary:
- Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. this document informs of how to diagnose t
- Bulletin:
- V001401 2033846
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Technical bulletin (fuel additive to help prevent sporadic misfire faults): fuel quality impacts the operating performance, efficiency and service life of the engine. the use of poor quality fuels may result in deposit build up on the fuel
- Bulletin:
- V011401 2028609
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (update programming for engine control module and transmission control module, for shudder and/or slight hesitation concerns): the current ecm/tcm programming could be causing slight hesitation related concerns in dsg eq
- Bulletin:
- V281401 2032116
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (incorrect glow plug faults): during the initial glow phase, after switching the ignition ?on?, the ecm performs a check of the glow plugs through the glow plug control module, to ensure the correct glow plugs are instal
- Bulletin:
- PDI - GOLF GTI T
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Golf/gti perfect delivery inspection (pdi) - technician and detailer inspections:
- Bulletin:
- On-car Analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- V511402 2038990
- Component:
- 162000 structure:body
- Summary:
- Technical bulletin (rocker panel - front fender ? corrosion): this document informs of corrosion on contact surfaces of the front fender to rocker panel (side member). this document discusses the "fault codes" necessary to diagnosis, and
- Bulletin:
- V011423 2034012
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Technical bulletin (manifold absolute pressure range / performance issues): this document informs that the monitoring strategy for the manifold absolute pressure sensor being too sensitive, causing p0106 to incorrectly set in the engine co
- Bulletin:
- V001413 2033846
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (fuel additive to help prevent sporadic misfire faults): fuel quality impacts the operating performance, efficiency and service life of the engine. the use of poor quality fuels may result in deposit build up on the fuel
- Bulletin:
- TT 45-06-122
- Component:
- 200000 wheels
- Summary:
- Tech tips (active wheel speed sensor diagnosis): this document informs of a procedure to diagnose active wheel speed sensor complaints
- Bulletin:
- TT 26-14-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tech tips (oxygen sensor reset procedures): this document informs of the procedure to rest oxygen sensors -for 2009-2014 vehicles with engine codes cjaa or cbea: -for 2012-2015 vehicles with engine codes ckra, cvca or crua:
- Bulletin:
- TT 00-14-03
- Component:
- 118000 electrical system: software
- Summary:
- Tech tips (svm update instructions): this document informs when performing svm updates, the scan tool should be hardwired to the vehicle and the bluetooth physically turned off. a hard wired internet connection is also recommended.
- Bulletin:
- VWR-17-01
- Component:
- 140000 air bags
- Summary:
- This document reminds dealers that takata sdi frontal airbag inflators replaced with the 69m9 safety recall will not be requested for return through the warranty parts portal but will be requested for return through the takata xpo return pr
- Bulletin:
- V641502 2039887
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Technical bulletin (rear door glass inoperative): the rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. this document contains the fault codes,
- Bulletin:
- V241504 2038161
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- Technical bulletin: this document has the fault codes to trouble shoot intake manifold faults. it also contains the claim codes for warranty coverage
- Bulletin:
- V201502 2031426
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (high pressure fuel pump diagnosis): completing the gff high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements
- Bulletin:
- V211504 2026771
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin:engine lacks performance, and engine warning light on issues. the document contains fault codes for trouble shooting issues, and procedures for those issues
- Bulletin:
- TT 44-13-04
- Component:
- 010000 steering
- Summary:
- Tech tips: this tech tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel off center
- Bulletin:
- TT 44-13-03
- Component:
- 020000 suspension
- Summary:
- Tech tips: this tech tip provides an overview of vehicle four wheel alignment, and important steps that should be followed when performing four wheel alignments
- Bulletin:
- V601501 2019568
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Technical bulletin (sunroof or power sunshade, does not open/close or automatic operation does not function). this document contains warranty information for coverage, and informs of methods to to service the issue
- Bulletin:
- V401501 2040561
- Component:
- 010000 steering
- Summary:
- Technical bulletin (squeaking noises from front of vehicle): squeaking/creaking noise from front of vehicle while fully turning steering wheel. the document also gives information on servicing the issue
- Bulletin:
- TT 64-14-02
- Component:
- 110000 electrical system
- Summary:
- Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. the check must be performed with the engin
- Bulletin:
- TT 19-13-02
- Component:
- 060000 engine and engine cooling
- Summary:
- Tech tips (coolant leak or repeat coolant leak from the water pump area): the document informs to inspect for issues, and why issues may happen. it also notes how to fix the issue, and other issues that could happen while repairing the iss
- Bulletin:
- TT 21-10-02
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Tech tips: the document discusses the conditions of when turbo can to be fixed or replaced
- Bulletin:
- TT 23-15-01
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Tech tips (exhaust gas recirculation system performance issues): after replacing the mass air flow sensor basic setting must be reset. this document informs of the procedure necessary to perform the reset
- Bulletin:
- V231503 2041063
- Component:
- 080000 fuel system, diesel
- Summary:
- Technical bulletin (no start, or rough running issues): when diagnosing the condition(no start, or rough running) on a common rail diesel vehicle, if no root cause is found after checking all other components and all gff diagnostic procedu
- Bulletin:
- V921502 2026253
- Component:
- 130000 visibility
- Summary:
- Technical bulletin (windshield wipers streak or smear): windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. to avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w
- Bulletin:
- V871508 2005566
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (hvac, unpleasant odor): unpleasant odor is coming from heating and ventilation system. odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
- Bulletin:
- V871506 2019947
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (air conditioning, cleaning of the refrigerant circuit (u.s.only)): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon
- Bulletin:
- V261507 2031583
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Technical bulletin (exhaust pressure control valve / exhaust gas recirculation flow issues): this document contains the fault codes needed to diagnose, and service the issue. the document contains the fault codes necessary to check warranty
- Bulletin:
- V241505 2038161
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (intake manifold runner position sensor issues): this document informs what repairs are needed to fix the issue. this document contains the fault codes necessary to check the warranty coverage for servicing this issue.
- Bulletin:
- V201503 2031426
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin: high pressure fuel pump diagnosis. completing the gff high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. this document contains the procedure to update
- Bulletin:
- V011521 2034898
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (exhaust gas recirculation flow insufficient stored in ecm fault memory): high soot loads prior to regeneration can cause possible restrictions in the egr filter. this document contains the procedure to update the program
- Bulletin:
- V011518 2023591
- Component:
- 080000 fuel system, diesel
- Summary:
- Technical bulletin (tdi clean diesel i/m (inspection maintenance) testing issues due to readiness not set): a volkswagen tdi clean diesel is not ready for i/m (inspection maintenance) testing due to readiness codes not being fully set. som
- Bulletin:
- TT 90-11-10
- Component:
- 117000 digital instrument panel
- Summary:
- Tech tips (instrument cluster production mode): this document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster.
- Bulletin:
- V401502 2033347
- Component:
- 356000 equipment adaptive
- Summary:
- Technical bulletin (cv boot replacement): the recommended procedure for removing damaged cv boot.
- Bulletin:
- V231505 2041063
- Component:
- 080000 fuel system, diesel
- Summary:
- Technical bulletin (fuel rail/system pressure, and pressure sensor issues): when diagnosing the fuel rail/system pressure, and pressure sensor issue condition on a common rail diesel vehicle, if no root cause is found after checking all ot
- Bulletin:
- V241703 2045138
- Component:
- 060000 engine and engine cooling
- Summary:
- Remove engine coolant from parts table.
- Bulletin:
- V201701 2031426
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update parts table.
- Bulletin:
- TT911101
- Component:
- 110000 electrical system
- Summary:
- Update to existing tech tip 91-11-01 for later model years, to direct technicians to the bluetooth compatibility chart.
- Bulletin:
- V871618_2043704
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated to include additional model year and required documentation instruction.
- Bulletin:
- V871617_2044165
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated vendor code and parts table.
- Bulletin:
- V941402 2011521
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Technical bulletin (exterior lights, moisture accumulation): exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic
- Bulletin:
- V871401 2005566
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (hvac, unpleasant odor): unpleasant odor is coming from heating and ventilation system. odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
- Bulletin:
- V691402 2029767
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (airbag warning lamp illuminated in instrument cluster): airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp. this document informs on how to diagnose that thi
- Bulletin:
- V401401 2033347
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin (cv boot replacement): recommended procedure for removing damaged cv boot. this document informs of the expected condition of a cv boot upon removal
- Bulletin:
- V231403 2036656
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Technical bulletin (no start, or rough running due to fuel rail issues): when diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all gff diagnostic procedures
- Bulletin:
- V231402 2036656
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Technical bulletin (no start, or rough running issues): when diagnosing a mil on, no-start or rough running concern on a common rail diesel vehicle, and no root cause is found after following all gff diagnostic procedures, it may be necess
- Bulletin:
- V151402 2032150
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (proper removal of engine cover to avoid breakage): pulling on the engine cover in some areas can cause damage. this document informs on the procedure to remove the engine cover.
- Bulletin:
- V011408 2014815
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin the use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -excessive accumulation of
- Bulletin:
- V011407 2014603
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin this technical bulletin details the general process for carrying out a software version management (svm) software update for any technical bulletin (tsb) / required vehicle update (rvu).
- Bulletin:
- V011406 2034012
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (manifold absolute pressure range / performance stored in ecm fault memory): monitoring strategy for the manifold absolute pressure sensor is too sensitive, causing p0106 to incorrectly set in the engine control module.
- Bulletin:
- TT 40-13-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tech tips (cv boot leaking grease, clamp not tight or not aligned properly): the document informs on what to do if the vehicles cv boot is having issues
- Bulletin:
- V871402 2005566
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (hvac, unpleasant odor): condensation, which is a normal condition in all a/c systems, can cause a musty odor. if the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i
- Bulletin:
- V461403 2015173
- Component:
- 045000 service brakes, air:disc
- Summary:
- Technical bulletin (brake disc pulsation or vibration): when applying brakes at highway speeds the following symptoms may occur: ? brake pedal pulsation ? vibration felt in vehicle body ? steering wheel shakes a detailed brake disc ins
- Bulletin:
- V281402 2032116
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (incorrect glow plug faults): during the initial glow phase, after switching the ignition ?on?, the ecm performs a check of the glow plugs through the glow plug control module, to ensure the correct glow plugs are instal
- Bulletin:
- V261402 2018962
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (tdi common rail high pitch whine noise after switching ignition off): with the implementation of the new ?clean diesel technology?, changes to the egr system were implemented as compared to previous diesel engines. aft
- Bulletin:
- V211403 2026771
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (engine lacks performance, engine warning light on): engine does not have any power and the engine warning light may be on. this document discusses the "fault codes" necessary to diagnosis, and potential remedy of the
- Bulletin:
- V011411 2034898
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Technical bulletin (exhaust gas recirculation flow, could be accompanied with soot accumulation): high soot loads prior to regeneration can cause possible restrictions in the egr filter. the production solution for this issue is new softwa
- Bulletin:
- V001404 2010380
- Component:
- 350000 equipment
- Summary:
- Technical bulletin (squeaks, rattles, noise, repair materials): this doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
- Bulletin:
- Reference - Refl
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- TT 91-14-02
- Component:
- 118000 electrical system: software
- Summary:
- Tech tips (mdi functions with iphone 5 variants (5, 5c, 5s and ipad fourth generation, ipod nano seventh generation)): the apple iphone 5, iphone 5c, and iphone 5s, as well as the ipad 4th generation and ipod nano 7th generation use a prop
- Bulletin:
- TT 91-11-09
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Tech tips (all navigation radios-all models): when the navigation rns 850/510/315 is in 3d mode, the top portion of the screen may not display streets. this line represents the horizon and is a normal operation of system. this document pro
- Bulletin:
- V921402 2037322
- Component:
- 350000 equipment
- Summary:
- Technical bulletin (washer level sensor): the issue is caused by the outside influence of non-approved formulated washer fluids. non-approved washer fluids leave a clear film coating on the sensor probes, insulating the probes so they cann
- Bulletin:
- V211404 2025464
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (frozen charge air cooler ? engine will not start): engine will not start after standing in cold weather below 0°c (32°f), mil may be illuminated with various induction and/or boost system faults stored in ecm. moisture
- Bulletin:
- TT 97-14-01
- Component:
- 137000 visibility:rear window wiper/washer
- Summary:
- Washer level sensor issues: the indicator lamp in the i.p. for washer fluid remains illuminated and the washer reservoir is full. this documet explains thelocation of the procedure to validate that the washer reservoir is full with the pro
- Bulletin:
- TT 92-14-02
- Component:
- 137000 visibility:rear window wiper/washer
- Summary:
- Tech tips (washer level sensor issues): this document discusses approved windshield washer fluids and the damages non - approved fluids can cause. the document also informs on the procedure to validate the washer reservoir is full with the
- Bulletin:
- TT 57-12-06
- Component:
- 350000 equipment
- Summary:
- Tech tips (alarm system activates immediately after opening the door when using the key): the alarm siren may activate immediately after opening the door, after unlocking using the physical key. a delay time of 15 seconds can be utilized t
- Bulletin:
- TT 24-13-03
- Component:
- 110000 electrical system
- Summary:
- Tech tips (engine control module fault p130a ?hide cylinder?): this document informs that dtc p130a ?hide cylinder? indicates that excessive misfiring has occurred. as a result, the ecm has turned off a fuel injector to prevent catalyst da
- Bulletin:
- Profi Outbound R
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Profi dealer vehicle information request form: this document informs of the requirements to test vehicles for an upcoming vw campaign. it contains the number of vehicles to be tested, and what is to be tested.
- Bulletin:
- V171403 2017813
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (oil consumption measurement): customer states oil consumption is higher than the volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. in order to provide effective lubricati
- Bulletin:
- TT 57-10-11
- Component:
- 110000 electrical system
- Summary:
- Tech tips (comfort module (j393) or bcm (j519) replacement): this document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched off. this can be accomplished by selec
- Bulletin:
- TT 21-10-01
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Tech tips 92006-2014 vehicles with 2.0t gasoline engine - n75 solenoid valve diagnosis): when diagnosis on the above engine leads to the testing of the n75, please refer this document with graphical aid. the diagram shows which vacuum port
- Bulletin:
- TT 20-09-06
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Tech tips (tdi engine - n75 solenoid valve diagnosis): this document informs with graphical aid the testing of the n75 solenoid valve in the event of a turbocharger fault code such as p0299 or p0234. this applies to mechanical injection st
- Bulletin:
- TT 011505
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tip to perform gff feedback for test plan issues.
- Bulletin:
- TT 011504
- Component:
- 118000 electrical system: software
- Summary:
- Seach tips to assist in finding dtc information
- Bulletin:
- V911306 2022739
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (bluetooth system identification): this document informs how to identify the various bluetooth systems by: ? visual identification ? pr code ? part number
- Bulletin:
- V911305 2031136
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (update programming rcd-510 radio (premium 8)): programming contained in software level(s) for certain rcd-510 radio (premium 8) radios may cause bluetooth audio quality complaints for model year 2012, and 2013. the p
- Bulletin:
- V691301 2029767
- Component:
- 140000 air bags
- Summary:
- Technical bulletin (airbag warning lamp illuminated in instrument cluster, dtc b101614 stored in airbag control module): the airbag lamp in instrument cluster may illuminate due to unfastened connector for passenger airbag warning lamp. t
- Bulletin:
- V261301 2031583
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Technical bulletin (exhaust pressure control issues): this document informs that water and road salt can corrode the exhaust flap shaft causing it to stick in open / closed position. the production solution to this issue was improved parts
- Bulletin:
- V011307 2032871
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (update programming - mil on, dtc p240f stored in ecm fault memory): the following fault code (p240f) may be stored in the ecm fault memory concerning (exhaust gas recirculation slow response). this document informs
- Bulletin:
- TT 96-12-03
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tech tips (kessy system ? loss of 15 power): this document informs of the procedure to perform if terminal 15 (key in run) power is lost before, during, or after any immobilizer adaptation.
- Bulletin:
- TT 90-11-10
- Component:
- 117000 digital instrument panel
- Summary:
- Tech tips (instrument cluster production mode): during pdi, or after installation of a replacement cluster, ?pro? may be displayed in place of the odometer. the high beam indicator may be flashing in the instrument cluster as well. this in
- Bulletin:
- TT 00-13-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tech tips (technician helpline vehicle check sheets): when it becomes necessary to open a vw technician helpline vta case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it
- Bulletin:
- Dealer Letter -
- Component:
- 090000 fuel system, other
- Summary:
- Volkswagen dealership communication (upcoming communication to owners of 2009-2013 my volkswagen tdi clean diesel engine vehicles registered in the state of illinois - using biodiesel fuel blends): due to illinois state tax incentives for
- Bulletin:
- VSS 17-08
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Vss 17-08 - tdi monitoring program - campaigns 23q3/23u4/23u3 2.0l emissions modification - gen i, gen ii and gen iii.
- Bulletin:
- VSS 17-06
- Component:
- 020000 suspension
- Summary:
- Notification of the 2.0l gen 1, tdi remediation fix monitoring via the vta system, in alignment with campaigns 23u3.
- Bulletin:
- V201702 2034072
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated to include an additional diagnostic trouble code (p04f0)
- Bulletin:
- TT 261704
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Tips to address specific dtcs that can result from an exhaust leak.
- Bulletin:
- TT 200901
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update to existing tip for fuel quality checking.
- Bulletin:
- TT 011708
- Component:
- 118000 electrical system: software
- Summary:
- Precautionary steps to error code erp0203e when performing campaign 23u3.
- Bulletin:
- TT 011503
- Component:
- 070000 fuel system, gasoline
- Summary:
- Update to expand fuel testing for lean dtcs.
- Bulletin:
- TT 001701
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tip to reinforce dealer scan tool update importance in regards to 24cv campaign.
- Bulletin:
- V241708 2045138
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update information regarding top tier brochure.
- Bulletin:
- ODIS Service Dia
- Component:
- 118000 electrical system: software
- Summary:
- Download odis service diagnostic version for 24cv recall.
- Bulletin:
- 24CV - Dealer Co
- Component:
- 060000 engine and engine cooling
- Summary:
- Inlet air box housing snow flap replacement & oxygen sensor inspection/replacement. the snow flap in the inlet air box housing may remain partially to fully open. should this occur, excess warm air could enter the air intake through the sno
- Bulletin:
- 24CV - Circular
- Component:
- 060000 engine and engine cooling
- Summary:
- Inlet air box housing snow flap replacement & oxygen sensor inspection/replacement. the snow flap in the inlet air box housing may remain partially to fully open. should this occur, excess warm air could enter the air intake through the sno
- Bulletin:
- 24CV - Circular
- Component:
- 060000 engine and engine cooling
- Summary:
- Inlet air box housing snow flap replacement & oxygen sensor inspection/replacement. the snow flap in the inlet air box housing may remain partially to fully open. should this occur, excess warm air could enter the air intake through the sno
- Bulletin:
- 24CV - Circular
- Component:
- 060000 engine and engine cooling
- Summary:
- Inlet air box housing snow flap replacement & oxygen sensor inspection/replacement. the snow flap in the inlet air box housing may remain partially to fully open. should this occur, excess warm air could enter the air intake through the sno
- Bulletin:
- 23U3 - Circular
- Component:
- 060000 engine and engine cooling
- Summary:
- 2.0l tdi engine (gen 1) emissions modification - customer only (retail sold) usa only - the environmental protection agency and california air resources board have determined that volkswagen vehicles equipped with a 2.0l 4-cylinder tdi eng
- Bulletin:
- 23U3 - Circular
- Component:
- 060000 engine and engine cooling
- Summary:
- 2.0l tdi engine (gen 1) emissions modification - customer only (retail sold) usa only - the environmental protection agency and california air resources board have determined that volkswagen vehicles equipped with a 2.0l 4-cylinder tdi eng
- Bulletin:
- 23U3 - Circular
- Component:
- 060000 engine and engine cooling
- Summary:
- 2.0l tdi engine (gen 1) emissions modification - customer only (retail sold) usa only - the environmental protection agency and california air resources board have determined that volkswagen vehicles equipped with a 2.0l 4-cylinder tdi eng
- Bulletin:
- 23U3 - Circular
- Component:
- 060000 engine and engine cooling
- Summary:
- 2.0l tdi engine (gen 1) emissions modification - customer only (retail sold) usa only - the environmental protection agency and california air resources board have determined that volkswagen vehicles equipped with a 2.0l 4-cylinder tdi eng
- Bulletin:
- V661301 2027119
- Component:
- 160000 structure
- Summary:
- Technical bulletin (damage on external chrome or aluminum surfaces) the surfaces of chrome parts can get damaged in the production process or by external influences. this document discusses options for repairs covered under warranty, and
- Bulletin:
- V481303 2030353
- Component:
- 010000 steering
- Summary:
- Technical bulletin (poor power steering assistance): this document informs of voltage drop in power steering control unit (j500) at start up or during steering operation leading to poor power steering assistance. the production solution
- Bulletin:
- V341301 2034406
- Component:
- 100000 power train
- Summary:
- Technical bulletin (manual transmission noise diagnosing): customer states there is a noise from the clutch, transmission or driveline components under varying driving conditions with varying sound levels. this document informs the deal
- Bulletin:
- V201306 2034072
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Technical bulletin activated charcoal filter system, solenoid valve 1 -n80- (canister purge valve) diagnosis): completing the gff function test and performing a vacuum check on the canister purge valve -n80- are essential to diagnose prop
- Bulletin:
- V171302 2017813
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (oil consumption measurement): customer states oil consumption is higher than the volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. in order to provide effective lubrica
- Bulletin:
- TT 91-13-06
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Tech tips (equipped with rcd-510 premium 8 radio - radio switches to bluetooth audio without input): if the radio is switching to the bluetooth audio selection whenever a paired phone makes any sound, such as typing or an incoming email
- Bulletin:
- TT 90-12-04
- Component:
- 117000 digital instrument panel
- Summary:
- Tech tips (service interval settings after instrument cluster replacement): after instrument cluster replacement, service interval maximum values may need to be manually set. this document informs how to set the values manually.
- Bulletin:
- TT 44-11-01
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Tech tips (brake electronics (abs) fault code 02757 diagnosis tip): this document informs if the battery has a low state of charge or is disconnected, fault code 02757 "adapting tire pressures" may set in address 03 - brake electronics.
- Bulletin:
- TT 26-13-01
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Tech tips (equipped with 2.0l tdi engine - engine control module fault p2413 "exhaust gas recirculation system performance" diagnosis tip): when diagnosing ecm fault p2413 "exhaust gas recirculation system performance", pressure test tur
- Bulletin:
- PDI - GOLF GTI T
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- golf perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purch
- Bulletin:
- Campaign Circula
- Component:
- 080000 fuel system, diesel
- Summary:
- Service action campaign (certain 2009-2012 model year vehicles with tdi clean diesel engine install misfueling guard): as diesel engine passenger vehicles become more popular, auto manufacturers have seen an increase in the number of mis
- Bulletin:
- Dealer Letter -
- Component:
- 080000 fuel system, diesel
- Summary:
- Volkswagen dealership communication (service action 20t8 install misfueling guard): volkswagen has received feedback from some vehicle owners in localized areas who have concerns about their ability to refuel their vehicle after the 20t8
- Bulletin:
- Dealer Letter an
- Component:
- 070000 fuel system, gasoline
- Summary:
- Volkswagen dealership communication (revision to service action 20t8 faq install misfueling guard): this document informs with a faq for service action 20t8 has been revised to include additional information for dealers to share with custo
- Bulletin:
- Dealer Letter-FA
- Component:
- 070000 fuel system, gasoline
- Summary:
- Volkswagen dealership communication (revision to service action 20t8 install misfueling guard): this document informs effective immediately, the work procedure for service action 20t8 has been revised to exclude the spring-loaded flap inse
- Bulletin:
- V921302 2024878
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Technical bulletin (wiper blade inspection for proper warranty coding): wiper blade inspection guidelines for wear and tear, outside influence or a factory issue. this document informs what is under coverage for wiper blade issues.
- Bulletin:
- V371301 2033975
- Component:
- 100000 power train
- Summary:
- Technical bulletin (automatic transmission fluid requirements): at this time, volkswagen group of america, volkswagen canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used to
- Bulletin:
- V281303 2032116
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (cylinder glow plug issues): during the initial glow phase, after switching the ignition "on", the ecm performs a check of the glow plugs through the glow plug control module, to ensure the correct glow plugs are install
- Bulletin:
- V271301 2033978
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (generator replacement): this document informs of charging system inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing. from this condition one or more of the following sympto
- Bulletin:
- V201305 2031426
- Component:
- 070000 fuel system, gasoline
- Summary:
- Technical bulletin (high pressure fuel pump diagnosis): completing the gff high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. this document informs how to perform the di
- Bulletin:
- V011317 2034012
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (manifold absolute pressure range / performance stored in ecm fault memory): monitoring strategy for the manifold absolute pressure sensor is too sensitive, causing fault code p0106 to incorrectly set in the engine con
- Bulletin:
- V011316 2034046
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (update programming of ecm for concerns of a bump sensation after coming to a stop): current ecm programming may cause a bump after coming to a stop, which may be felt through the chassis of the vehicle. this concern is
- Bulletin:
- TT 37-11-05
- Component:
- 100000 power train
- Summary:
- Tech tips (measure value block request): if a request has been made for several mvbs from a dsg transmission, the test plan "read measured values for obligation to report" can be selected. this function will retrieve all of the mvbs from t
- Bulletin:
- TT 21-13-01
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Tech tips (equipped with turbocharged engine turbocharger replacement tip): if mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. thi
- Bulletin:
- PDI - GOLF GTI T
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Golf perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purcha
- Bulletin:
- Email TDI Update
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- E-mail tdi odis aem update.
- Bulletin:
- V871620 2005566
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model and model year applicability.
- Bulletin:
- V691601 2010479
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model year applicability to include 2017.
- Bulletin:
- V341602 2034406
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Additional symptom gathering information and guidence to isolate customer concern before beginning repair.
- Bulletin:
- Campaign Tip - 6
- Component:
- 141000 air bags:frontal
- Summary:
- Campaign tip - 69m8 and 69m9 - takata part label information
- Bulletin:
- Takata Enrollmen
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Takata enrollment form
- Bulletin:
- V871622 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Update to model year applicability.
- Bulletin:
- V871621 2043893
- Component:
- 353600 equipment:air conditioner
- Summary:
- Updated to include additional model year applicability.
- Bulletin:
- V851603 2041609
- Component:
- 138110 visibility:defroster/defogger system:windshield:blower
- Summary:
- Update model year applicability.
- Bulletin:
- V401602 2040561
- Component:
- 010000 steering
- Summary:
- Updated to include model year 2017 applicability
- Bulletin:
- V371602 2033975
- Component:
- 103000 power train:automatic transmission
- Summary:
- Updated to include an additional model year applicability.
- Bulletin:
- V191602 2022549
- Component:
- 110000 electrical system
- Summary:
- Update model year applicability.
- Bulletin:
- V011615 2014815
- Component:
- 060000 engine (pws)
- Summary:
- Update to include additional model year applicability.
- Bulletin:
- V001605 2033846
- Component:
- 060000 engine (pws)
- Summary:
- Updated to include additional model year applicability.
- Bulletin:
- VWP-13-13
- Component:
- 060000 engine (pws)
- Summary:
- Secondary air pressure sensor limited warranty extension. volkswagen has extended the emission control systems warrantly for secondary air pressure sensor replacement under specific conditions to 10 years or 120,000 miles whichever occurs f
- Bulletin:
- V011616 2028609
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- To update warranty table service number and labor operation number.
- Bulletin:
- V001607 2034407
- Component:
- 103000 power train:automatic transmission
- Summary:
- Update to include model year 2017 applicability.
- Bulletin:
- TT 00-16-02
- Component:
- 350000 equipment
- Summary:
- Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used
- Bulletin:
- STP4-STP6 UPDATE
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Informing of a update of codes for the inventory vehicle open campaign/action report
- Bulletin:
- Update 02122016
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
- Bulletin:
- Customer Letter
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This document infroms the customer of the decision to extend the emissions control systems warranty for the intake manifold & fuel injectors certain 2011-2012 model year volkswagen vehicles with 2.0 tfsi engine (engine codes cbfa & ccta)
- Bulletin:
- On-Car Analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-Car Analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- TT 011507
- Component:
- 110000 electrical system
- Summary:
- Alternative repair direction to address dtc p1386 on the 2.5l engine. update to include beetle and beetle convertible applicability.
- Bulletin:
- V871618 2043704
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated to include additional model year and required documentation instruction.
- Bulletin:
- FTC Dealer Notic
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This notice gives an update on the settlement for the emissions issues with regards to 2.0l tdi vehicles.
- Bulletin:
- TT 97-12-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- data link connector pin assignment chart that is applicable to all models. update model year applicability.
- Bulletin:
- V871617 2044165
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated vendor code and parts table.
- Bulletin:
- Circular - 20T8
- Component:
- 080000 fuel system, diesel
- Summary:
- Service action campaign: as diesel engine passenger vehicles become more popular, auto manufacturers have seen an increase in the number of misfueling cases where diesel engine vehicles are mistakenly fueled with gasoline. as an additional
- Bulletin:
- V871701 2044165
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- To add associated labor operation numbers to warranty table and include model year 2017 applicability.
- Bulletin:
- V571701 2042955
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update technical bulletin to include model year 2016 and 2017 models.
- Bulletin:
- V241702 2045138
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This technical bulletin was updated per powertain team and warranty team. info from this bulletin is combined with tb 2031075 (v241208) and 2038161 (v241506) due to warranty extension claiming/processing confusion. (basically 3 technical
- Bulletin:
- 1-2017 Update
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This communication is to update our profi dealers of the current status of the latest inbound and outbound profi requests.
- Bulletin:
- WECF HPFP WEXT
- Component:
- 080000 fuel system, diesel
- Summary:
- Volkswagen dealership communication: this document announced a warranty volkswagen extension program to cover the high pressure fuel pump on 2009-2012 model year tdi clean diesel engine vehicles.
- Bulletin:
- Dealer Letter -
- Component:
- 080000 fuel system, diesel
- Summary:
- Volkswagen dealership communication: volkswagen announced a warranty extension program to cover the high pressure fuel pump on 2009-2012 model year tdi clean diesel engine vehicles
- Bulletin:
- Dealer Letter -
- Component:
- 080000 fuel system, diesel
- Summary:
- Volkswagen dealership communication: this document is a faq concerning question customers may have about volkswagen installing a preventative safeguard to prevent the pumping of gasoline instead of diesel into the volkswagen vehicles with
- Bulletin:
- Ref. - Reflash U
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide of the vehicles expected upgraded software level. the latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
- Bulletin:
- Campaign Circula
- Component:
- 080000 fuel system, diesel
- Summary:
- Emissions service action (certain 2010-2014 volkswagen vehicles with 2.0l tdi® clean diesel engine ecm software update): the vehicle?s engine management software has been improved to assure the vehicle?s tailpipe emissions are optimized a
- Bulletin:
- Elsa 6-22-15
- Component:
- 350000 equipment
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, elsapro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
- Bulletin:
- Elsa 6-29-15
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
- Bulletin:
- Takata - Parts a
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Takata - parts allocation update - dealer communication
- Bulletin:
- VWoa Dealer Anno
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This document informs of volkswagen ag and audi ag received notice from the us environmental protection agency, us department of justice and the california air resources board of an investigation related to emissions compliance matters.
- Bulletin:
- VST-16-01
- Component:
- 131000 visibility:windshield
- Summary:
- Explaination of cross car distorion when looking through the windshield and how the "effect" in normal.
- Bulletin:
- Bulletin 69M8 an
- Component:
- 140000 air bags
- Summary:
- Campaign parts bulletin - 69m8 and 69m9 - today, may 5th is the final standard weekly allocation of takata airbag inflators. after this date, takata allocations will be based on the previous week?s paid claim volume. it is critical that c
- Bulletin:
- Customer FAQ - T
- Component:
- 350000 equipment
- Summary:
- This document gives answers to frequently ask questions concerning the current owners and lessees of tdi vehicles affected by the emissions issue eligiblality options and issues.
- Bulletin:
- Recall 69M8-69M9
- Component:
- 140000 air bags
- Summary:
- Campaign parts bulletin - 69m8 and 69m9 - takata part ordering process - on may 5th, a campaign parts bulletin about the updated takata part ordering process was sent to all dealers. we?ve closely monitored the impact of that communication
- Bulletin:
- TT571004 2031440
- Component:
- 110000 electrical system
- Summary:
- Updated direction to address no communication concerns with the -j519- vehicle electrical system control module.
- Bulletin:
- V011625 2028609
- Component:
- 060000 engine (pws)
- Summary:
- Update service number and labor operation number.
- Bulletin:
- Campaign Circula
- Component:
- 118000 electrical system: software
- Summary:
- Emissions service action: the vehicle?s engine management software has been improved to assure the vehicle?s tailpipe emissions are optimized and operating efficiently.
- Bulletin:
- Dealer Letter -
- Component:
- 080000 fuel system, diesel
- Summary:
- Volkswagen dealership communication: the vehicle?s engine management software has been improved to assure the vehicle?s tailpipe emissions are optimized and operating efficiently for volkswagen vehicles equipped with a 2.0l tdi clean dies
- Bulletin:
- Customer Letter
- Component:
- 080000 fuel system, diesel
- Summary:
- Warranty extension for high-pressure fuel pump: volkswagen informed customers of a decision to extend the warranty for the high-pressure fuel pump (hpfp) in the tdi® clean diesel engine vehicle under specific conditions to 10 years or 120
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
- Bulletin:
- V171701 2012855
- Component:
- 060000 engine and engine cooling
- Summary:
- 17 17 01 july 5, 2017 2012855 supersedes technical bulletin 17-16-02 (v171602) dated april 29, 2016 due to updated oil standards lists to current specifications. engine oils which meet volkswagen oil quality standards
- Bulletin:
- 69M8 and 69M9 Ow
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This communication gives more information on the repair & owner mobility update
- Bulletin:
- 69M8 and 69M9 Ca
- Component:
- 140000 air bags
- Summary:
- This communication informs the dealers of details on the takata parts allocation/ordering.
- Bulletin:
- Emissions Recall
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Updated work procedure, 2010 model year pre-repair aftertreatment system inspection.
- Bulletin:
- TT001703
- Component:
- 118000 electrical system: software
- Summary:
- Tip for scan tool concerns that may occur duing a test plan
- Bulletin:
- V011711 2034898
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Modify service instruction and to update gff time expenditure in the warranty table.
- Bulletin:
- V871714 2043704
- Component:
- 353600 equipment:air conditioner
- Summary:
- Updated to include additional models and model year applicability.
- Bulletin:
- A971861 2013504-
- Component:
- 110000 electrical system
- Summary:
- This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns
- Bulletin:
- SM 59-2017
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This special notice is to inform dealers to return all part numbers listed in the document. only superseded part numbers to be ordered going forward.
- Bulletin:
- SM 12-2017 VWMEX
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This special notice is to inform dealers to return all part numbers listed in the document. only superseded part numbers to be ordered going forward.
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns(including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaint: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns (including clutch assembly, bevel box and haldex)
Home | Privacy