9999 CUMMINS WESTPORT ISX12 G Recall
- Campaign:
- 14E003000 on 02/20/2014
- Component:
- Engine and engine cooling:engine
- Manufactured:
- 02/18/2013 - 02/01/2014
- Affected:
- 25,013
- Defect:
- Cummins inc. and cummins westport inc. are recalling certain cummins westport model isl g engines manufactured september 12, 2007, through february 2, 2014, and cummins westport model isx12 g engines manufactured february 19, 2013, through february 2, 2014. condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
- Consequence:
- The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a fire or burn injury to a person near the exhaust pipe.
- Correction:
- Cummins inc. and cummins westport inc. will notify owners, and dealers will upload a new ecm calibration, free of charge. cummins inc. and cummins westport inc. began notifying the affected vehicle manufacturers on february 14, 2014. the recall began on april 12, 2014. for more information owners may call 1-800-343-7357. cummins' number for this recall is c1462 (for isl g engines) or c1461 (for isx12 g) engines.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
9999 CUMMINS WESTPORT ISX12 G TSBs (23)
- Bulletin:
- TSB150180-110915
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new low pressure regulator fuel control cover. the low pressure regulator can collect condensation and under certain conditions the low pressure regulator can freeze after the engine is shutdown
- Bulletin:
- TSB150200-122115
- Component:
- 070000 fuel system, gasoline
- Summary:
- This technical service bulletin provides the information regarding proper troubleshooing of fault code 2725.
- Bulletin:
- TSB160017-021616
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin communicates the release of a new lubricating oil filter bypass valve. the oil filter bypass valve can leak, caused by improper sealing of the lubricating oil filter bypass valve plunger in the lubricating o
- Bulletin:
- TSB150196-121615
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin desribes the troubleshooting steps to diagnose natural gas leaks into the engine cooling system. many natural gas fuel systems use engine coolant to warm the natural gas high pressure regulator and/or heat
- Bulletin:
- TSB150191-121415
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces the release of a new lubricating oil cooler element, which has been updated to prevent copper leaching into the engine lubricating oil.
- Bulletin:
- TSB140060-050814
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin discribes the verification and resolution of fault codes 155 and/or 2964 due to intake manifold temperature sensor failures with a certain date code range exhibiting a high rate of early life failures.
- Bulletin:
- T1486
- Component:
- 060000 engine (pws)
- Summary:
- This temporary repair practice authorizes repair locations to remove and discard the laminar flow screen on certain engines when working on the fuel control housing or removing the fuel transfer tube.
- Bulletin:
- TSB140013-022714
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of certain fault codes occuring while operating in temperatures below freezing (32 degrees f). condensation forms in the charge-air cooler, exhaust gas recirculation
- Bulletin:
- TSB130151-012114
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of suceptability to low coolant fault diagnostics due to coolant sensor wiring in kenworth t600, t800 and w900 chassis. some of these vehicles were built with incorr
- Bulletin:
- TSB140013-012514
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of certain fault codes occuring while operating in temperatures below freezing (32 degrees f). condensation forms in the charge-air cooler, exhaust gas recirculation
- Bulletin:
- TSB150133-092515
- Component:
- 060000 engine (pws)
- Summary:
- This techical service bulletin announces the release of new exhaust manifold gaskets and manfolds and new upper engine gasket kit part numbers to reduce instances of lkeaing exhaust manifold gaskets and cracked exhaust manifolds.
- Bulletin:
- TSB150127-072715
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of idle surge caused by low pressure regulator oscillations. fault codes 6396 or 1861 may be associated with an oscillating low pressure regulator.
- Bulletin:
- TSB103765-060215
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin revises the service procedure clean and inspect for reuse for non-shielded spark plugs.
- Bulletin:
- TSB150095-061215
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- This technical service bulletin announces the release of new turbocharger turbine housing repair kits.
- Bulletin:
- TSB150065-050615
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new oxygen sensor wire harness adapter. the adapter provides a solid barrier between the oxygen sensor and the engine wiring harness, preventing inacccurate readings of the oxygen sensor.
- Bulletin:
- TSB150068-051115
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verfication and resolution of fault code 2722 due to a low pressure regulator housing casting defect.
- Bulletin:
- TSB140060-040915
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin discribes the verification and resolution of fault codes 155 and/or 2964 due to intake manifold temperature sensor failures with a certain date code range exhibiting a high rate of early life failures.
- Bulletin:
- TSB150045-040615
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes verification and resolution of repeat visits for engine misfire, engine stumble, or reduced spark plug life due to ignition coil failures not detected during repair or maintenance events.
- Bulletin:
- TSB150032-030915
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin introduces the release of a revised piston, piston rings, piston kit, and piston ring set and explains interchangeability.
- Bulletin:
- TSB150038-031715
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin describes the proper troubleshooting and repair steps for egr cooler leaks. this is address egr coolers that are erroneously replaced due to signs of moisture in the egr cooler or egr crossover tube and hard
- Bulletin:
- TSB140170-121114
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new intake manifold cover for the engine. the new intake manifold changes the location and orientiation of the intake manifold pressure/temperature sensor to a revised location on the intake man
- Bulletin:
- C1989B
- Component:
- 060000 engine (pws)
- Summary:
- This campaign is being issued to address a calibration update in certain isx12 g cm2180ej engines. this document enables authorized repair locations to calibrate the engine control module (ecm) to the latest revision. this is a revision to
- Bulletin:
- C2039
- Component:
- 060000 engine (pws)
- Summary:
- This campaign addresses a calibration update in certain engines. the campaign enables authorized repair locations to calibrate the engine control module to the latest revision.
Home | Privacy