9999 NAVISTAR NAVISTAR TSBs (160)
- Bulletin:
- BCM9900004
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject pertaining to 230/250 ht horsepower engines. *tt
- Bulletin:
- BCM991006
- Component:
- 110000 electrical system
- Summary:
- Information regarding the use of the prolink to program a new vpm module. *mjs
- Bulletin:
- BCM991005
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information regarding requesting a horsepower quote for a navistar engine. *mjs
- Bulletin:
- BCM000101
- Component:
- 162300 structure:body:door
- Summary:
- Information regarding the afc-99907 door trim panels that were released for replacement of the right and left door lower trim panels. *mjs
- Bulletin:
- BCM000102
- Component:
- 052200 parking brake:driveline:air
- Summary:
- The parking brake control valve on vehicle's with hydraulic brakes with an air released, spring applied transmission mounted parking brake. *mjs
- Bulletin:
- G98903
- Component:
- 350000 equipment
- Summary:
- Subject regarding navistar md navpak. *tt
- Bulletin:
- TSI-08-02-01
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Navistar: dana/spicer tie rod end inspection procedures. all models that have a dana/spicer/international front axle. this procedure instruct you when tie rod end need to be replaced. *pe
- Bulletin:
- AFC-08908R
- Component:
- 980000 unknown or other
- Summary:
- Navistar: one piece high pressure pump oil fitting replacing the snap to connect style fitting. the snap to connect (stc) fitting could wear out prematurely resulting in an internal high pressure oil leak and hard start or no start conditio
- Bulletin:
- TSB-08906
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Navistar truck: replacement of fuel transfer (lift) pump. a worn check valve in the pump can cause loss of fuel pressure which may result in degraded engine performance. models 1300, 3200 3300, 4300, 4400, 7300, 7400, 7500, 8500, ce, cxt, f
- Bulletin:
- TSI-091402
- Component:
- 022520 suspension:rear:axle:non-powered axle assembly
- Summary:
- Navistar: on hendrickson 14uhk suspensions only, the torque value of the (4) suspension saddle bolts/nuts has changed. the torque value of the bolt/nut has increased. models 5500i, 5600i, 5900i, 7400, 7500, 7600, 7700, 9200i, 9400i, 9900i,
- Bulletin:
- SB-IK-0400062
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Navistar: navistar hydraulic abs software will not communicate with abs module. these system use a single communication wire from the abs ecu to pin 6 (or f) of the 6 pin diagnostic connector. abs light on and will not shut off; cannot c
- Bulletin:
- IK-0500031
- Component:
- 013200 steering:gear box:shaft pitman
- Summary:
- International truck and engine: torque procedure for installing all steer gears. *rm
- Bulletin:
- IK-0500030
- Component:
- 013200 steering:gear box:shaft pitman
- Summary:
- International truck: torque for installing the pittman arm on the steering gear. *rm
- Bulletin:
- PL-0200002
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- International truck: tie rod replacement. *rm
- Bulletin:
- IK-0800258
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- International truck: low voltage light is on, alternator appears to not charge, sudden drop of voltage, no start. there is a false indication that the alternator is not charging. *rm
- Bulletin:
- IK-1200555
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- International truck: the air control valve is sensitive to vibration which can cause noise in the signal or bad connections. there are four possible trouble codes. *rm updated 8/17/11. *pe updated 2/27/12. *pe
- Bulletin:
- IK-1200562
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- International truck: turbocharger mounting bolt installation and procedure. *rm
- Bulletin:
- IK-1200558
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- International truck: an emissions label shows the wrong settings. *rm
- Bulletin:
- MIN-11117
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- International truck: high pressure pump mounting bolt torque procedure. *rm
- Bulletin:
- MIN-11118
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- International truck: the rear engine mount snubber washer may have been installed incorrectly. *rm
- Bulletin:
- MIN-11122
- Component:
- 022520 suspension:rear:axle:non-powered axle assembly
- Summary:
- International truck: the procedure to remove the spring spacer between the forward rear axle spring and the axle seat which are not required. *rm
- Bulletin:
- MIN-11123
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- International truck: installation process for replacement of shorter than required left and right fuel tank front hanger bracket bolts. *rm
- Bulletin:
- SFN-11-11
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- International truck: high pressure fuel system plugs are being shipped. *rm
- Bulletin:
- AFC-11907
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Navistar: information on recalibrating the engine control module. *rm
- Bulletin:
- AFC-11909
- Component:
- 044300 service brakes, air:drum:chamber
- Summary:
- International truck: the rear brake chambers are changed from diaphragm to piston type. *rm
- Bulletin:
- MIN-11112
- Component:
- 060000 engine and engine cooling
- Summary:
- Navistar: information on updated calibration of the ecm. *rm
- Bulletin:
- IK-1200618
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- International truck: there are problems with the fuel pump. hard start/ no start, dtc codes, engine runs rough, loss of throttle response, engine warning light. *rm
- Bulletin:
- MIN-11133
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Navistar: certain engines were built with a high pressure fuel pump that went through a rework process by our supplier that could result in a fuel leak inside of the engine. the leak can result in a no start condition, fuel in the oil or po
- Bulletin:
- IK-1300124-1
- Component:
- 050000 parking brake
- Summary:
- International truck: the auto neutral park brake switch information. *rm updated 5/9/12. *js
- Bulletin:
- IK-1200633-1
- Component:
- 060000 engine and engine cooling
- Summary:
- International truck: engine lamp will come on when dtc's are set. engine will start to lose power or derate due to the engine warning protection system. *rm updated 12/19/13. *pe updated 04/24/2014 *js updated 9/15/15
- Bulletin:
- IK-0500038
- Component:
- 010000 steering
- Summary:
- Navistar: steering goes into a shimmy after hitting a bump. *rm updated 3/20/12. *pe
- Bulletin:
- IK-1200655
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Navistar: the injection pressure regulator (ipr) pigtail would have a no start, or the engine would idle roughly, or the engine stalls out. *pe updated 4/3/12. *pe updated 1/07/13. *pe updated 4/1/13. *pe u
- Bulletin:
- IK-2200016
- Component:
- 350000 equipment
- Summary:
- Navistar buses: the post trip inspection system does not operate correctly or will not disarm. this issue effects all buses, pre 2007 and post 2007. *pe
- Bulletin:
- IK-1200628
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- International: on certain engines, the inlet screen on ipr valve was removed and added to oil intake port of high pressure pump. no model or model year truck listed. *pe
- Bulletin:
- IK-0400101
- Component:
- 046000 service brakes, air:antilock
- Summary:
- Bendix dtc 155 is on. in order to get rid of this code. vehicles need to get the latest version of acom installed. *kb
- Bulletin:
- IK-0800341
- Component:
- 118500 electrical system: integrated trailer brake control
- Summary:
- Auxiliary switch lamp burning out on vehicles equipped with feature code 0008tth. navistar. *kb
- Bulletin:
- IK-1200727
- Component:
- 040000 service brakes, air
- Summary:
- Engine brake housing corrosion on maxxforce 15 engine. navistar. *kb
- Bulletin:
- IK-2200115
- Component:
- 160000 structure
- Summary:
- Specialty manufacturing stop arms, roof hatches and crossing gates information for buses. navistar. *kb
- Bulletin:
- PB305
- Component:
- 026000 traction control system
- Summary:
- Navistar: automatic traction control (atc) indicator light will not illuminate when atc mode is activated due to a missing circuit. school bus. *kb
- Bulletin:
- 12105
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Navistar: high pressure fuel pump washers for certain vehicles with 2010 maxxforce 15 engines, flagged with min# 12105, and built from 1/14/2011 to 11/16/2011. *js
- Bulletin:
- 12113
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Navistar: this min applies to to 37 terrastar, durastar, and workstar trucks and ic bus models, model dates/21/12 to 4/4/2012. *js
- Bulletin:
- 0800330
- Component:
- 341000 communications:horn assembly
- Summary:
- Navistar: pc and re bus series - revised horn contact assembly. replace the pin-style electric horn contact assembly with the improved roller-wheel horn contact design. this applies to models pc02500, pc04500, re30030, and pc05500 model yea
- Bulletin:
- MIN-13102
- Component:
- 107000 power train:axle hubs
- Summary:
- Navistar: front axle hub grease inspection.this procedure applies only to vehicles flagged with min#13102. school bus models ae, be, ce, and re built 4 december 2012 to 2 january 2013. *js
- Bulletin:
- IK0800095
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Iknow: troubleshooting for brake pressure light. *js updated 03/07/2014 *js
- Bulletin:
- IK-2200122
- Component:
- 220000 seats
- Summary:
- Iknow: inspect and if necessary repair the passenger seat back pan. this applies to be, ce, re school and commercial buses. start date february 2010 through august 2011. refer to tsi 13-47-01. *js
- Bulletin:
- IK-1200321
- Component:
- 060000 engine (pws)
- Summary:
- International: on certain trucks, when cold and have no start or crank, engine has hard start and run rough. no models or model years listed. *pe
- Bulletin:
- MIN-13107
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Navistar: vehicles that were built from 1/14/2011 through 10/14/2013 with 2010 maxxforce engines, require the missing spacers and new mounting bolts to be installed on the high pressure fuel pump. no models were provided. *js
- Bulletin:
- AFC-12941
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: some vehicles may display an engine warning light paired with fault codes or engine misfire. this is due to open injector circuits caused by spread terminals on the under valve cover injector harness. models include: durastar, ter
- Bulletin:
- TSI-13-12-10
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: this bulletin includes information on the removal and installation of the exhaust manifold ring seals for the front and rear exhaust manifold fey ring joints. *js
- Bulletin:
- TSI-13-04-01
- Component:
- 111000 electrical system:battery
- Summary:
- Navistar: information pertaining to the frame mounted battery box and air drier procedure. model ce bus. no model years were provided.*js
- Bulletin:
- TSI-13-12-18
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: information on how to correct the misalignment of the egr cooler housing bolt hole pattern. *js
- Bulletin:
- TSI-13-12-19
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: information involving the removal of the fuel cooler valve screen. this reduces high fuel temperature on some vehicles. models include durastar, terrastar, and ic bus. built before september 1, 2011. *js
- Bulletin:
- MIN-13113
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: some vehicles may have been built without the airline from the air drier to engine to purge valve fitting. including model prostar built between march 20, 2013 and july 08, 2013.*js
- Bulletin:
- SFN-1320
- Component:
- 010000 steering
- Summary:
- Navistar: some vehicles may exhibit a rubbing noise coming from the steering column. models include terrastar vehicles and ae buses. no model years provided.*js
- Bulletin:
- TSI-13-12-05
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Navistar: information concerning the replacement procedure for high pressure turbocharger cartridge. involving maxxforce 11 and 13, epa 10, navistar n13 engine, and 2013 maxxforce 13 hdobd. *js
- Bulletin:
- TSI-13-12-17R1
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: procedural information on the required cleaning of charge air coolers (cacs) that experience internal contamination. no model or years listed. *pe
- Bulletin:
- TSI-13-12-20
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Navistar: information provided regarding partial or entire replacement of crankcase breather assembly and also an addendum for installation of crankcase breather for certain engines. .*pe
- Bulletin:
- TSI-13-12-21
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: installation procedures for exhaust manifold ring seal for standard torque trucks due to an exhaust leak from exhaust manifold fey ring joints. model maxxforce. no years listed. *pe
- Bulletin:
- TSI-13-12-11
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Navistar: the high pressure (hp) turbocharger center section (cartridge) needs to be replace and instruction information is provided. model maxxforce. no years listed. *pe
- Bulletin:
- IK-1200948
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- International: a high temperature exhaust gas recirculation cooler housing (htegrc) to mid plate alignment. model maxxforce 11, 13, epa 10, navistar n13, 2013 maxxforce 13 hdobd. *pe
- Bulletin:
- AFC-13918
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: some engines may have damage at the fuel shut-off valve (fsov) pressure sensor. this can occur when the fuel line is not replaced before reprogramming the electrical control module (ecm) and aftertreatment control module (acm). mo
- Bulletin:
- IK-1201029
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ik: after updated calibration, no adverse affect to vehicle or engine, and mil light will not illuminate due to code dtc spn 629 fmi 0 (ecm cpu load) and code can be disregarded. *pe updated 3/24/14. *pe
- Bulletin:
- IK-1201007
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: information on proper procedures in handling regen issues, such as low power, no start, engine dies, warning lamps in cluster and constantly requiring regens, for engine. *pe updated 3/20/14. *pe
- Bulletin:
- IK-0800109
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Iknow: there may be some vehicles that experience excessive moisture and/or debris inside the headlights. it is not necessary to replace the entire headlamp. *js
- Bulletin:
- TSI-13-12-13
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Navistar: information provided regarding leaking exhaust from exhaust manifold fey ring joints and procedures on installing exhaust manifold ring seal (exhaust cuff) for cylinder 2 and 3 exhaust manifold fey ring joint. model maxxforce dt
- Bulletin:
- SP-13518
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Navistar: an emission recall requiring recalibration of engine ecm, cleaning of diesel oxidation catalyst (doc), inspection for plugged exhaust back pressure (ebp)tube, resetting oil level to reduce excessive fuel dilution and doc face plu
- Bulletin:
- IK-1201004
- Component:
- 060000 engine (pws)
- Summary:
- International: certain engines uses a fuel module, incorporating many features, including an electric fuel pump and fuel pump strainer that can be seen when pump is removed from filter module and strainer should be serviced at filter repla
- Bulletin:
- IK-1201055
- Component:
- 080000 fuel system, diesel
- Summary:
- International: some trucks, either code will illuminate lamp on dash/instrument cluster, engine calibration will release to correct false setting of dtc, low fuel pressure diagnostic trouble codes 94-1 and 94-17 being erroneously set.
- Bulletin:
- IK-0400033
- Component:
- 190000 tires
- Summary:
- Iknow: compatible tire sizes are required for the appropriate performance of the traction control system. *js
- Bulletin:
- IK-0800483
- Component:
- 012000 steering:column
- Summary:
- Iknow: the steering wheel switch functions may not work. there may be routing issues if a harness rub concern is existent. *js
- Bulletin:
- IK-0800284
- Component:
- 060000 engine (pws)
- Summary:
- Iknow: this bulletin concerns information about the diagnostics, location, and faults pertaining to the ambient air temperature. applies to 2010 epa maxxforce 11 and 13 prostar and workstar. *js updated 02/12/2016 *ma
- Bulletin:
- IK-1100005
- Component:
- 101000 power train:clutch assembly
- Summary:
- Iknow: trouble shooting for eaton clutch. when the brake pedal is depressed there may be no clutch brake, noise may be heard, and clutch fork hits pressure plate. it may be stiff or hard to depress the pedal. vehicles include transtar, work
- Bulletin:
- MIN-14105
- Component:
- 100000 power train
- Summary:
- Navistar: an improper torque was applied to six left (driver) side, front iros suspension hanger, and two crossmember bolts. models ce c, ce s, re c, and re s buses built between november 25. 2013 and february 18, 2014. *js
- Bulletin:
- IK-1200404
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Navistar (international): due to combustion gases in fuel system, there would be misfiring, rough idling, poor performance and sometimes hard starting. model 2004-2007 466, 570. *pe
- Bulletin:
- IK-1200271
- Component:
- 060000 engine (pws)
- Summary:
- Navistar (international): information regarding options for remote throttle control of engine speed on hpv trucks by either wiring into rpm (remote power module) 60aja, 60aje, 60ajg, 60ajh, 60ajj or the engine ecm 12vyc can be wired direc
- Bulletin:
- IK-1200398
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Navistar (international): on some turbocharger engines, the variable turbine vanes would become inoperative due to internal corrosion of turbine housing flange. a turbocharger flange kit is available. *pe
- Bulletin:
- IK-1200099
- Component:
- 060000 engine (pws)
- Summary:
- Navistar (international): check ecm and idm power relays and wiring if ecm or idm clean power fuses are blown in battery box. idm loses power, will crank, but not start and ecm loses power, engine starts but have no throttle. *pe
- Bulletin:
- IK-0800183
- Component:
- 060000 engine (pws)
- Summary:
- Navistar (international): installation instructions provided regarding chafing by wires, if harness not routed and secured properly and can cause electrical short circuits, intermittently and engine shut down. *pe
- Bulletin:
- TSI-14-12-03
- Component:
- 060000 engine (pws)
- Summary:
- Navistar: information concerning the procedure to install the turbo oil supply tube retrofit. there is also are information that provides instructions on how to reroute certain coolant hoses. models include prostar 122, prostar 113, worksta
- Bulletin:
- IK-0400133
- Component:
- 353000 equipment:electrical
- Summary:
- Iknow: new retrofit kits for prostar vehicles have been developed to allow the flr-20 radar technology to be used after replacing flr-10 radar. *js
- Bulletin:
- IK-0400134
- Component:
- 030000 brakes (pws)
- Summary:
- Iknow: information concerning the brake light operation on the terrastar with hydromax brakes. *js
- Bulletin:
- IK-0800486
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Iknow: information concerning the inoperative lift gate. faullt code may be set for undercurrent on the circuit. *js
- Bulletin:
- IK-1200526
- Component:
- 070000 fuel system, gasoline
- Summary:
- Iknow: information concerning the maf sensor calibration for 2010 maxxforce dt, 9 and 10. *js updated 02/16/2016 *ma
- Bulletin:
- IK-1201119
- Component:
- 060000 engine (pws)
- Summary:
- Iknow: information concerning the cummins isx scr system wiring. there may be a complaint of warning light of the dashboard relating to the engine and/or possible engine de-rate. *js
- Bulletin:
- IK-1200822
- Component:
- 060000 engine (pws)
- Summary:
- Iknow: information pertaining to a leak detection pump tool. the tool permits high pressure oil leak to be detected without cranking the engine or using the ipr valve breakout harness. *js
- Bulletin:
- IK-1201134
- Component:
- 060000 engine (pws)
- Summary:
- Iknow: information concerning the service procedure for the 15l hp turbo center cartridge replacement. *js
- Bulletin:
- IK-1201148
- Component:
- 060000 engine (pws)
- Summary:
- Iknow: information concerning authorization for the replacement of all upper and lower rod bearing shells on some isx15 cm2350 x101 engines. *js
- Bulletin:
- IK1201039
- Component:
- 042000 service brakes, air:supply
- Summary:
- Iknowledge base: prostar, transstar, paystar, 9900i, isx cummins scr, n13 scr: bulletin information regarding aftertreatment purge air valve air supply line routing for both cummins isx scr engines and n13 with scr engines. *lj
- Bulletin:
- MIN-15105
- Component:
- 350000 equipment
- Summary:
- Wheelchair lift mounting bracket requires 8 mounting bolts but have been installed using only 4 bolts *cn
- Bulletin:
- IK-2700065
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Iknow: information regarding various software updates on ez tech computer and portal link to use for downloading. no model or years listed. *pe
- Bulletin:
- SB-MIN15109
- Component:
- 350000 equipment
- Summary:
- Navistar; procedure for correcting rear engine mount bolts. bolts not tightened to specific torque. *cn
- Bulletin:
- IK-3000075
- Component:
- 350000 equipment
- Summary:
- Iknow: information on the smart dispatch process, to identify the skill level, utilizing information from virtual triage to diagnosis and repair vehicle. no model or years listed. *pe
- Bulletin:
- IK0700079
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- IK0900115
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- IK1100031
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- IK1200753
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- IK1200991
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- IK1201133
- Component:
- 090000 fuel system, other
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- IK1900080
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 15112
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- WIL2800122
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Srt / se committee meeting notes and summary conference call january 2015
- Bulletin:
- WIL2800133
- Component:
- 060000 engine (pws)
- Summary:
- All 2010 emissions and scr engines srt's that require high pressure turbo oil supply line removal. the srt steps have been updated to install new for the installation of the h.p. line. once removed, the line is not to be reused.
- Bulletin:
- WIL2800135
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- System one used truck warranties are visible in the service portal vehicle summary page like any other service contract. differences to be aware of are:  start date, miles, and hours are not based upon original dtu date and miles
- Bulletin:
- AFC16904
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Diesel exhaust fluid quality sensor (dqs) recalibration to prevent inadvertent illumination of a dash warning light and improve vehicle uptime and customer satisfaction; models without aerodynamic skirts.
- Bulletin:
- AFC16905
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Diesel exhaust fluid quality sensor (dqs) recalibration to prevent inadvertent illumination of a dash warning light and improve vehicle uptime and customer satisfaction; models with aerodynamic skirts.
- Bulletin:
- IK0800038
- Component:
- 110000 electrical system
- Summary:
- Park lights come on whenever the key is on / headlight switch part numbers
- Bulletin:
- IK0800092
- Component:
- 110000 electrical system
- Summary:
- The first check to make when troubleshooting any body controller or esc issue
- Bulletin:
- IK1200909
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Complete high pressure turbocharger replacement guidelines
- Bulletin:
- IK1201242A
- Component:
- 060000 engine (pws)
- Summary:
- Hp turbocharger center section replacement procedure
- Bulletin:
- IK1201329
- Component:
- 060000 engine (pws)
- Summary:
- Cpa n13 full-load blow-by test (fl-bbt) tips
- Bulletin:
- IK1201338
- Component:
- 060000 engine (pws)
- Summary:
- Oil pump bushing replacement procedure
- Bulletin:
- MIN16124
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Certain prostar models may have been built without the heated mirror harneses.
- Bulletin:
- MIN16127
- Component:
- 060000 engine (pws)
- Summary:
- The engine oil filter may not be tightened to its specified value; propane engine only.
- Bulletin:
- IK0100033
- Component:
- 060000 engine (pws)
- Summary:
- Frame damage due to improper engine oil pressure testing location
- Bulletin:
- IK0700011
- Component:
- 110000 electrical system
- Summary:
- Regen can be inhibited by the pto (remote throttle input) staying active
- Bulletin:
- IK0800218
- Component:
- 060000 engine (pws)
- Summary:
- Accelerator position sensor/idle validation switch aps /ivs diagnostics, 3-box equipped engine control systems
- Bulletin:
- IK1200481
- Component:
- 350000 equipment
- Summary:
- Aftertreatment soot level reset after afi, dpf or doc cleaning or replacement
- Bulletin:
- IK1200598
- Component:
- 060000 engine and engine cooling
- Summary:
- Soot centrifuge - chassis mounted diagnostics (air & oil leaks)
- Bulletin:
- IK1200739
- Component:
- 060000 engine (pws)
- Summary:
- Egr valve diagnostics
- Bulletin:
- IK1201085
- Component:
- 060000 engine (pws)
- Summary:
- Engine calibration history
- Bulletin:
- IK1201086
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Egr cooler diagnostics
- Bulletin:
- IK1201089
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant in the exhaust
- Bulletin:
- IK1201090
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant in the intake
- Bulletin:
- IK1201091
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant leak to lube oil
- Bulletin:
- IK1201100
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Spn - 2659 fmi 21 egr low flow
- Bulletin:
- IK1201103
- Component:
- 060000 engine (pws)
- Summary:
- 1209-0 ebp above desired during acceleration
- Bulletin:
- IK1201113
- Component:
- 060000 engine (pws)
- Summary:
- Ht egr core removal/installation
- Bulletin:
- IK1201146
- Component:
- 060000 engine (pws)
- Summary:
- Ghost codes - false codes
- Bulletin:
- IK1201192
- Component:
- 060000 engine (pws)
- Summary:
- Over temperature diagnostics
- Bulletin:
- IK1201193
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant overflow diagnostics
- Bulletin:
- IK1201199
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine cooling system overflow diagnostics
- Bulletin:
- IK1201202
- Component:
- 110000 electrical system
- Summary:
- Procedure for recording 0-60 mph & lug down test
- Bulletin:
- SFN1420
- Component:
- 060000 engine (pws)
- Summary:
- Induction cleaning system tool kit amendment
- Bulletin:
- SFN1423
- Component:
- 060000 engine and engine cooling
- Summary:
- Air compressor lift tool kits were shipped with an incorrect part number.
- Bulletin:
- IK0400088
- Component:
- 040000 service brakes, air
- Summary:
- Brake single hot wheel end service procedure; air brakes only
- Bulletin:
- IK0800213
- Component:
- 060000 engine (pws)
- Summary:
- Remote mounted engine control feature 12vzb and 12vga wiring and connector information
- Bulletin:
- IK0800485
- Component:
- 117000 digital instrument panel
- Summary:
- Cluster issues
- Bulletin:
- IK1200006
- Component:
- 110000 electrical system
- Summary:
- Split-shaft does not work with the new bendix ec-60 or version 2 ec-30 controller; bendix air brakes only
- Bulletin:
- IK1200269
- Component:
- 060000 engine (pws)
- Summary:
- Split-shaft pto operation on dlcii (egr) engines
- Bulletin:
- IK1200598
- Component:
- 060000 engine (pws)
- Summary:
- Soot centrifuge - chassis mounted diagnostics (air & oil leaks)
- Bulletin:
- IK1200822
- Component:
- 060000 engine (pws)
- Summary:
- Icp system diagnostic information
- Bulletin:
- IK1200855
- Component:
- 060000 engine (pws)
- Summary:
- Eliminate harness rubbing at ecm bracket; only engines built prior to 9/1/2012
- Bulletin:
- IK1200909
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Complete high pressure turbocharger replacement guidelines
- Bulletin:
- IK1201004
- Component:
- 092100 fuel system, other:delivery:fuel pump
- Summary:
- Electric fuel pump step-based diagnostics
- Bulletin:
- IK1201062
- Component:
- 110000 electrical system
- Summary:
- Spn 3055 fmi 1 no start due to low fuel rail pressure troubleshooting
- Bulletin:
- IK1201063
- Component:
- 060000 engine (pws)
- Summary:
- Spn 3055 fmi 15 frp below minimum with maximum command troubleshooting
- Bulletin:
- IK1201091
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant leak to lube oil
- Bulletin:
- IK1201105
- Component:
- 060000 engine (pws)
- Summary:
- Engine hydro-locked
- Bulletin:
- IK1201113
- Component:
- 060000 engine (pws)
- Summary:
- Ht egr core removal/installation
- Bulletin:
- IK1201122
- Component:
- 060000 engine (pws)
- Summary:
- Rescue calibration boost specification difference
- Bulletin:
- IK1201130
- Component:
- 060000 engine (pws)
- Summary:
- Filter cleaning reference data
- Bulletin:
- IK1201139
- Component:
- 060000 engine (pws)
- Summary:
- Spn 94-18 low fuel pressure while cranking; only on obd engines
- Bulletin:
- REC14510
- Component:
- 060000 engine (pws)
- Summary:
- Engine software update for maxxforce dt engines to improve diesel particulate filter (dpf) regeneration performance
- Bulletin:
- 2016FA02 REV A
- Component:
- 060000 engine (pws)
- Summary:
- Announces a joint customer satisfaction campaign with navistar related to a potential quality issue related to the adaption hardware between the n13 engine and tc10 transmission and campaign to install a new flexplate.
- Bulletin:
- IK1201222
- Component:
- 060000 engine (pws)
- Summary:
- Maxxforce 7 misfire diagnostics
- Bulletin:
- IK0800320
- Component:
- 110000 electrical system
- Summary:
- Beacon lights; equipped with feature 08wzc and/or 08ace
- Bulletin:
- IK1201202
- Component:
- 118000 electrical system: software
- Summary:
- Procedure for recording 0-60 mph & lug down test
- Bulletin:
- IK1200962
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Cold side egr cooler replacement
- Bulletin:
- IK1201012
- Component:
- 060000 engine (pws)
- Summary:
- Dtc 731-16/18 knock detected
- Bulletin:
- IK1600197
- Component:
- 161000 structure:frame and members
- Summary:
- Wind noise coming from the right side of the cab; especially models with external air cleaners
Home | Privacy